RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Chat about your 6R/6C model Polos here!
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7787
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Post by ciclo »

smg_shardul wrote: Sun Oct 15, 2017 4:18 pm I am unable to take vcds scan report it’s not working properly

For cornering lamp of right side I tried to test from output test it’s working but when I steer to right side it’s goes off in 2 secs..

Any solution to this ?


Sent from my iPhone using Tapatalk
Your problem is that you bought the bixenon headlights 'repaired' and it seems that during the repair someone make a mistake with the positions of wires.....viewtopic.php?f=56&t=70289&start=75#p525570

For example, check the connections/wires inside the bixenon headlamp are in the right places (compare with left headlight).

I insist that I am not yet a fortune teller, magician o similar, but is likely what is happening with your right headlight.
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7787
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Post by ciclo »

Anything new about these little problems?
smg_shardul
Bronze Member
Posts: 176
Joined: Mon May 01, 2017 3:13 pm
Drives: Polo 6R
Location: Kolhapur

Re: RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Post by smg_shardul »

ciclo wrote:Anything new about these little problems?
Today I tried to connect licence plate light to Bcm as per instructions the bcm wire is to be connected to blue grey wire in boot door but there is no such wire present
All wires are white in colour and 2 wires connected to licence plate are also white in colour should I connect to +ve terminal of the wire ?
Below is the photo of connector of licence plate light .

Image


Sent from my iPhone using Tapatalk
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7787
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Post by ciclo »

Image
smg_shardul
Bronze Member
Posts: 176
Joined: Mon May 01, 2017 3:13 pm
Drives: Polo 6R
Location: Kolhapur

Re: RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Post by smg_shardul »

ciclo wrote:Anything new about these little problems?
Cornering light issue solved after replacing defused D3S bulb...
It’s working fine now.
Only 3 things left
1) dimmer switch
2) wiring to licence plate light
3) coming home (semi automatic )may be due to incorrect coding vcds scanned report I will share tomorrow some codes are different need to change.

Thanks ciclo without your guidance and wiring this DIY was impossible..



Sent from my iPhone using Tapatalk
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7787
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Post by ciclo »

Okay, do not worry, tomorrow we'll correct the BCM coding and do a BCM coding so that all the optional functions are activated.
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7787
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Post by ciclo »

:?:
smg_shardul
Bronze Member
Posts: 176
Joined: Mon May 01, 2017 3:13 pm
Drives: Polo 6R
Location: Kolhapur

Re: RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Post by smg_shardul »

sorry was really busy in work couldn't find time
here is the scanned report
i am unable to edit code so some codes are still not changed

Friday,27,October,2017,18:35:04:39744
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 17.8.0.1 (x64)
Data version: 20170721 DS276.2
www.Ross-Tech.com


VIN: MEXA16608GT067313 License Plate: ,MH9SHARDUL



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 60-VW25 (7E0)
Scan: 01 02 03 04 08 09 10 15 17 19 25 44 56 0B

VIN: MEXA16608GT067313

01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: Malfunction 0010
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
56-Radio -- Status: Malfunction 0010

-------------------------------------------------------------------------------
Address 01: Engine (J623-CWXB) Labels: None
Part No SW: 03L 906 023 SN HW: 03L 907 425 B
Component: R4 1.5l TDI H33 9977
Revision: --H33--- Serial number:
Coding: 00250116032500080000
Shop #: WSC 00000 000 08192
ASAM Dataset: EV_ECM15TDI20103L906023SN 001001
ROD: N/A
VCID: 040057528F805F66AE-8050

No ASAM data for: "EV_ECM15TDI20103L906023SN" (VW25)
No fault code found.
Readiness: 0 0 0 0 0

-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 0AM-927-769.clb
Part No SW: 0AM 300 065 L HW: 0AM 927 769 D
Component: GSG DSG AG7 431 6501
Revision: 00043014 Serial number: CU501510066015
Coding: 0000020
Shop #: WSC 01324 785 00200
VCID: 3878F3A24BC8CB8672-806C

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels:. 6R0-907-37x-ESP90.clb
Part No SW: 6R0 907 379 BN HW: 6R0 907 379 AS
Component: ESP9.0i front H03 0001
Serial number: --------------
Coding: 62DD2C63422907C74617346A4254E0820908
Shop #: WSC 28939 002 1048576
ASAM Dataset: EV_Brake1ES9P0iBOSCH 003031
ROD: N/A
VCID: 0B127C6EA2DE101EEF-805E

No ASAM data for: "EV_Brake1ES9P0iBOSCH" (VW25)
1 Fault Found
0931 - ROD - Unknown Error Code
- 00 [009]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 47
Mileage: 32861 km
Date: 2019.14.15
Time: 18:24:23


-------------------------------------------------------------------------------
Address 04: Steering Angle (G085) Labels:* None
Part No SW: 6R0 959 654 HW: 6R0 959 654
Component: LENKW.SENSOR H07 0070
Serial number: 26071513471359
Coding: 01
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_LWSKLOVW25X 005001
ROD: EV_LWSKLOVW25X_VW25.rod
VCID: 7EF425BAE16C35B6F8-802A

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels: 6R0-907-044.clb
Part No SW: 6R0 907 044 Q HW: 6R0 907 044 Q
Component: Climatronic H12 0615
Revision: V0000000
VCID: 418E9E46D8128A4EC5-8014

1 Fault Found
00457 - Control Module for Network (J519)
013 - Check DTC Memory - Intermittent
Freeze Frame:
Fault Status: 00101101
Fault Priority: 6
Fault Frequency: 1
Reset counter: 87
Mileage: 32861 km
Time Indication: 0
Date: 2019.14.15
Time: 18:31:40


-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: None
Part No SW: 7E0 937 090 C HW: 7E0 937 090 C
Component: BCM PQ25 Max4 H82 0752
Revision: B9082001 Serial number: 4000 173171271
Coding: 3A904BBF48E10200013807916CCB96905A88676F600D30C1200000030000
Shop #: WSC 28939 002 1048576
VCID: 2B52DCEE4A9E701E0F-807E

Subsystem 1 - Part No: 5K7 955 559 C
Component: RLS 080617 04 42 0106
Coding: 008F77

Subsystem 2 - Part No SW: 6R0 959 802 CC HW: 6R0 959 802 CC
Component: ------------- 007 5521
Serial number: 13102670151005153008
Coding: 050000

Subsystem 3 - Part No SW: 6R0 959 801 BT HW: 6R0 959 801 BT
Component: ------------- 007 5521
Serial number: 13202671151005132525
Coding: 050000

Subsystem 4 - Part No SW: 5TA 959 442 HW: 5TA 959 442
Component: E221__MFL-TAT H06 0023
Serial number: 2991519341401746AJ2B
Coding: 250000

Subsystem 5 - Part No SW: 6R0 959 811 L HW: 6R0 959 811 L
Component: ------------- 006 5520
Serial number: 13202580151005230949
Coding: 020000

Subsystem 6 - Part No SW: 6R0 959 812 L HW: 6R0 959 812 L
Component: ------------- 006 5520
Serial number: 13102581150929004312
Coding: 020000

2 Faults Found
01504 - Bulb for License-Plate Light (X)
010 - Open or Short to Plus
Freeze Frame:
Fault Status: 01101010
Fault Priority: 3
Fault Frequency: 1
Reset counter: 47
Mileage: 32861 km
Time Indication: 0
Date: 2019.14.15
Time: 18:26:39

02195 - Dimmer Switch Instrument Panel & Switch Lighting (E20)
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 3
Fault Frequency: 1
Reset counter: 87
Mileage: 32861 km
Time Indication: 0
Date: 2019.14.15
Time: 18:31:42


-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446) Labels: None
Part No SW: 7E0 919 475 J HW: 7N0 919 475
Component: PARKHILFE 8K H06 0105
Revision: -------- Serial number: 28261224902578
Coding: 300104
Shop #: WSC 02756 790 50316
ASAM Dataset: EV_VW75XAprkAssis8K 001003
ROD: N/A
VCID: 397EF6A6B8C2D28E8D-806C

No ASAM data for: "EV_VW75XAprkAssis8K" (VW25)
No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:. 5K0-959-655.clb
Part No SW: 6R0 959 655 J HW: 6R0 959 655 J
Component: VW10AirbagU06 H10 0020
Revision: -------- Serial number: 003GW0121NNF
Coding: 003036
Shop #: WSC 01234 785 00200
ASAM Dataset: EV_AirbaVW01BPAVW250 A01001
ROD: N/A
VCID: 499E8666E822420E1D-801C

No ASAM data for: "EV_AirbaVW01BPAVW250" (VW25)
No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:. 5K0-920-xxx-17.clb
Part No SW: 2H0 920 871 B HW: 2H0 920 871 B
Component: KOMBI H04 1009
Serial number: 00000000000000
Coding: 140A080000
Shop #: WSC 13202 938 12345
ASAM Dataset: EV_Kombi_UDS_VD_DRM09 A05730
ROD: N/A
VCID: 275A20DE5E76547EEB-8072

No ASAM data for: "EV_Kombi_UDS_VD_DRM09" (VW36 *)
No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 7E0-909-901.clb
Part No SW: 7E0 909 901 HW: 7E0 937 090 C
Component: GW-K-CAN TP20 H82 0752
Revision: B9082001
Coding: 102300
Shop #: WSC 28939 002 1048576
VCID: 68D863E29BE89B0622-803C

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels:. 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H04 1009
Serial number: 00000000000000
Coding: 000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_Immo_UD_SVDD_RM09 A03710
ROD: N/A
VCID: 6ADC19EA8DE4A91634-803E

No ASAM data for: "EV_Immo_UD_SVDD_RM09" (VW36 *)
No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist (J500) Labels:. 1Sx-909-144-44.clb
Part No SW: 1S2 909 144 P HW: 1S2 909 144 P
Component: EPS_ECU H61 1702
Coding: 0001000000000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_SteerAsssiNSK 014008
ROD: N/A
VCID: 418E9E46D0128A4EC5-8014

No ASAM data for: "EV_SteerAsssiNSK" (VW25)
No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (J503) Labels:. 5M0-035-1xx-56.clb
Part No SW: 6RD 035 187 A HW: 6RD 035 187 A
Component: MIB2-S-R-CN 025 0210
Revision: -----001 Serial number: 02425GD0000489
Coding: 0000044004000A
Shop #: WSC 00081 790 00133
VCID: 45868A56CC3AA66EF9-8010

3 Faults Found
00876 - Treble Speaker Rear Left (R14)
011 - Open Circuit
Freeze Frame:
Fault Status: 01101011
Fault Priority: 5
Fault Frequency: 1
Reset counter: 47
Mileage: 32861 km
Time Indication: 0
Date: 2019.14.15
Time: 18:26:08

00875 - Treble Speaker Front Right (R22)
011 - Open Circuit
Freeze Frame:
Fault Status: 01101011
Fault Priority: 5
Fault Frequency: 1
Reset counter: 47
Mileage: 32861 km
Time Indication: 0
Date: 2019.14.15
Time: 18:26:08

00874 - Treble Speaker Front Left (R20)
011 - Open Circuit
Freeze Frame:
Fault Status: 01101011
Fault Priority: 5
Fault Frequency: 1
Reset counter: 47
Mileage: 32861 km
Time Indication: 0
Date: 2019.14.15
Time: 18:26:08


End-------------------------(Elapsed Time: 02:55)--------------------------
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7787
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Post by ciclo »

Ok, we'll wait for you to install the Dimmer :?: and connect the license plate lights.
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7787
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Post by ciclo »

smg_shardul wrote: Mon Oct 23, 2017 8:29 am Hi Fernando ,
How to find difference between part number ?
I want to find the difference between part Number 6R2941039A, 6R2941039B, 6R2941039C, 6R2941039D
Can you help me out here ?

Regards
Shardul.
https://ifinterface.com/page/page3.php?langid=1 ... how does it work? :arrow: viewtopic.php?f=10&t=42713#p466570

Image

therefore, the difference is in the date in which these models bixenon headlights were installed.
Left --- for 6R RHD
smg_shardul
Bronze Member
Posts: 176
Joined: Mon May 01, 2017 3:13 pm
Drives: Polo 6R
Location: Kolhapur

Re: RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Post by smg_shardul »

ciclo wrote:
smg_shardul wrote: Mon Oct 23, 2017 8:29 am Hi Fernando ,
How to find difference between part number ?
I want to find the difference between part Number 6R2941039A, 6R2941039B, 6R2941039C, 6R2941039D
Can you help me out here ?

Regards
Shardul.
https://ifinterface.com/page/page3.php?langid=1 ... how does it work? :arrow: viewtopic.php?f=10&t=42713#p466570

Image

therefore, the difference is in the date in which these models bixenon headlights were installed.
Left --- for 6R RHD

This means any part from 4 of them can be fitted to one vehicle?


Sent from my iPhone using Tapatalk
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7787
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Post by ciclo »

No, all parts of a system (set of parts) must be of the same production dates according to ETKA.
ETKA will tell you if the parts are compatible with each other.

These previous links are also included in the installation guide... :|
smg_shardul
Bronze Member
Posts: 176
Joined: Mon May 01, 2017 3:13 pm
Drives: Polo 6R
Location: Kolhapur

RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Post by smg_shardul »

My friend is having polo sedan his existing car have only fog lamps he upgraded Bcm which supports cornering lamps and he want to connect it to fog lamps how to connect it?
If we connect just two wires T73/B9 & T73/B10 to +ve of fog lamp will it work ?
Thanks in advance


Sent from my iPhone using Tapatalk
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7787
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Post by ciclo »

Maybe, ...show me a fuse box picture and an autoscan from that Polo Sedan.
smg_shardul
Bronze Member
Posts: 176
Joined: Mon May 01, 2017 3:13 pm
Drives: Polo 6R
Location: Kolhapur

Re: RLS ,CH/LH , Auto lights , Rain sensing wiper & Auto dimming Rear view mirror on Vento

Post by smg_shardul »

ciclo wrote:Maybe, ...show me a fuse box picture and an autoscan from that Polo Sedan.
Ok I will share you vcds scanned report and fuse box pic by tomorrow
Thanks ..
Regards
Shardul..


Sent from my iPhone using Tapatalk
Post Reply