numberior´s 2011 Polo 6R GTI DSG

Chat about your 6R/6C model Polos here!
numberior
New
Posts: 43
Joined: Thu Sep 21, 2017 3:34 pm
Drives: Polo GTI 6r
Location: Singapore

Re: numberior´s 2011 Polo 6R GTI DSG

Post by numberior »

Hi Ciclo,
Yes, there is some difference in the wires reaching the Light switch/Dimmer connectors.
- Blue / Gray = Yellow / Gray (T17 connector, and T6 connector)
- You must also remove/isolate the T17/6 original wire.

---
I left out T17/6.
Will get to doing it.....just thought I tell you in case it's causing the error. :roll:
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7786
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: numberior´s 2011 Polo 6R GTI DSG

Post by ciclo »

numberior wrote: Thu Oct 19, 2017 5:27 pm
When I switched off engine, the cabin light is on until I leave the car and locks the car by remote.
When I unlock the car by remote, cabin light comes on, then turns off when ignition on.
I did not know at time of testing to observe the headlight and tail light also. Was not familiar with this feature.
Will observe again tomorrow.
This function was already coded in your previous BCM. It is absolutely correct.
What is the problem?

If you do not want this function, uncheck Byte12 Bit2

numberior wrote: Thu Oct 19, 2017 5:27 pm
Latest scan gave error on reverse lamp diagnostic, which I find strange as diagnostics for backup lamp is already disabled.
It comes back even after clearing the DTCs.
I'm using full LED taillights https://item.taobao.com/item.htm?spm=a1 ... uav4oqe1eb
by the way.
As I said, the faults shown in the autoscan are due to the use of non-original parts, the coding is perfect. :wink:

Replace them by OEM parts ...

numberior wrote: Thu Oct 19, 2017 5:27 pm
Another error is related to xenon range module.
I'm using LED H7 bulbs https://www.philips.com.sg/c-p/12985BWX ... light-bulb for the cornering lamps.
I can change them out for halogen if required.
Yes, change them... by H7 55W.



Image
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7786
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: numberior´s 2011 Polo 6R GTI DSG

Post by ciclo »

numberior wrote: Thu Oct 19, 2017 5:34 pm Hi Ciclo,
Yes, there is some difference in the wires reaching the Light switch/Dimmer connectors.
- Blue / Gray = Yellow / Gray (T17 connector, and T6 connector)
- You must also remove/isolate the T17/6 original wire.

---
I left out T17/6.
Will get to doing it.....just thought I tell you in case it's causing the error. :roll:
Remove/isolate, and everything will work as it should. :wink:
numberior
New
Posts: 43
Joined: Thu Sep 21, 2017 3:34 pm
Drives: Polo GTI 6r
Location: Singapore

Re: numberior´s 2011 Polo 6R GTI DSG

Post by numberior »

okie Ciclo,
thanks for your help again :)
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7786
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: numberior´s 2011 Polo 6R GTI DSG

Post by ciclo »

numberior wrote: Thu Oct 19, 2017 5:27 pm
Regarding our bi-xenon headlamps: will they perform a up/down sweeping range check each time the engine is started?
Because I don't see them doing it, even after xenon range basic setting is accepted.
They should do this every time you make a new ignition cycle.

--

To try to solve the problem of back-up lamp (with Taobao taillights) do this BCM coding:
3CB02BBF08A1000008380CC16C2B0CD05AC0672F60051040200000030000

I will never be in favor of losing the diagnosis of such an important lamp.
numberior
New
Posts: 43
Joined: Thu Sep 21, 2017 3:34 pm
Drives: Polo GTI 6r
Location: Singapore

Re: numberior´s 2011 Polo 6R GTI DSG

Post by numberior »

Hi Ciclo,

I retained your BCM coding. The worker at the body shop broke my reverse lamp wire(was modded for RHD). I've since repaired it so
now no fault code in BCM. I've temporarily disabled hi-beam diagnostic while waiting for halogen ones to come in.

One last problem though.... the headlight range module is not working. :(
I've checked connections at sensor, re-seated the connector and checked the wires to the AFS control module.
The AFS is supplied with permanent +12V as in Kufatec's instruction. I'm not sure if it's the cause. :roll:

I seem to be having similar issues as "sanders" viewtopic.php?f=56&t=68178&start=105

Code: Select all

Monday,23,October,2017,16:55:31:27502
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64
VCDS Version: 17.8.0.1 (x64)
Data version: 20170721 DS276.2
www.Ross-Tech.com


VIN: WVWZZZ6RZBY312116   License Plate: 12TH SCAN
Mileage: 100290km-62317mi   Repair Order: 



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 6R-VW25 (7E0)
Scan: 01 02 03 04 08 09 15 17 19 25 44 55 56 0B

VIN: WVWZZZ6RZBY312116   Mileage: 100290km-62317miles

01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
55-Headlight Range -- Status: Malfunction 0010
56-Radio -- Status: Cannot be reached 1100
 
-------------------------------------------------------------------------------
Address 01: Engine (J623-CAVE)       Labels:. 03C-907-309-V1.clb
   Part No SW: 03C 906 027 AR    HW: 03C 906 027 AR
   Component: 1.4l R4 TSI   H15 9971  
   Revision: L2H15---    Serial number: 00000000000000
   Coding: 00250012002400000000
   Shop #: WSC 12345 123 12345
   ASAM Dataset: EV_ECM14TSI01103C906027AR 001014
   ROD: EV_ECM14TSI01103C906027AR.rod
   VCID: 71E99E02A0C274CE75-8024

No fault code found.
Readiness: 0010 0101

-------------------------------------------------------------------------------
Address 02: Auto Trans
Cannot be reached

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels:. 6R0-907-37x-ESP82.clb
   Part No SW: 6R0 907 379 AK    HW: 6R0 907 379 AF
   Component: ESP8.2i front H05 0001  
   Revision: --------    
   Coding: 230248E3416E02B4C42612E382D740811700
   Shop #: WSC 00788 648 00255
   VCID: 071DD0DAB2465A7ECB-8052

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels: 6R0-907-044.clb
   Part No SW: 6R0 907 044 E    HW: 6R0 907 044 E
   Component: Climatronic   H09 0609  
   Revision: V0000000    
   VCID: 35616A129C2A18EE69-8060

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:. 7E0-937-BCM-V1.clb
   Part No SW: 7E0 937 090 B    HW: 7E0 937 090 
   Component: BCM PQ25 Max4 H81 0744  
   Revision: B9081001    Serial number: 0982 321160318
   Coding: 3CB02BBF08A1000008380C916C2B0CD05AC0670F60051040200000030000
   Shop #: WSC 12345 123 12345
   VCID: 2A5B496E45944716F4-807E

   Subsystem 1 - Part No SW: 6R0 959 802 AB    HW: 6R0 959 802 AB  Labels: 6R0-959-802.CLB
   Component: J386__TSG_FT  007 1611 
   Serial number: KU0KU024031100012688
   Coding: 18BC30

   Subsystem 2 - Part No SW: 6R0 959 801 AD    HW: 6R0 959 801 AD  Labels: 6R0-959-801.CLB
   Component: J387__TSG_BT  007 1611 
   Serial number: KU0KU016031100015781
   Coding: 08BC30

   Subsystem 3 - Part No SW: 6R0 959 591 A    HW: 7P0 959 591 
   Component: J245 PS72.015  H05 0006 
   Serial number:     WOO1165901/     
   Coding: 081001

   Subsystem 4 - Part No SW: 5K0 959 542     HW: 5K0 959 542 
   Component: E221__MFL-TAS  H05 0010 
   Serial number: 0050759             
   Coding: 830000

   Subsystem 5 - Part No SW: 6R0 959 811 G    HW: 6R0 959 811 G
   Component: J388__TSG_HL  007 1611 
   Serial number: KU0KU011041100017315
   Coding: 08BC32

   Subsystem 6 - Part No SW: 6R0 959 812 G    HW: 6R0 959 812 G
   Component: J389__TSG_HR  007 1611 
   Serial number: KU0KU011041100013053
   Coding: 08BC32

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels:| 5K0-959-655.clb
   Part No SW: 6R0 959 655 M    HW: 6R0 959 655 M
   Component: VW10Airbag01E H09 0020  
   Revision: --------    Serial number: 003GZ000HCNK
   Coding: 003145
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_AirbaVW10BPAVW250 A01001
   ROD: EV_AirbaVW10BPAVW250_VW25.rod
   VCID: 4C972FF6E7A0792626-8018

   Crash sensor for side airbag: driver side: 
   Serial number: 3575HRB40550HJHG9ON%

   Crash sensor for side airbag: front passenger side: 
   Serial number: 3585HRB40590HJHG919A

   Crash sensor for side airbag: rear: driver side: 
   Serial number: 3515RRB405B0I4AG6OGL

   Crash sensor for side airbag: rear: passenger side: 
   Serial number: 3525RRB404R0H4DUHPLR

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 5K0-920-xxx-17.clb
   Part No SW: 6R0 920 870     HW: 6R0 920 870 
   Component: KOMBI         H21 0320  
   Serial number: 00000000000000
   Coding: 140A00
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04086
   ROD: EV_Kombi_UDS_VDD_RM09_A04_VW25.rod
   VCID: 72EB910EA5C44FD68C-8026

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels:. 7E0-909-901.clb
   Part No SW: 7E0 909 901     HW: 7E0 937 090 
   Component: GW-K-CAN TP20 H81 0744  
   Revision: B9081001    
   Coding: 002300
   Shop #: WSC 12345 123 12345
   VCID: 68DFF3669B18B50622-803C

1 Fault Found:
01304 - Radio 
            004 - No Signal/Communication
             Freeze Frame:
                    Fault Status: 01100100
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 10
                    Mileage: 100245 km
                    Time Indication: 0
                    Date: 2012.03.13
                    Time: 23:57:39


-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels:| 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5K0 953 234 
   Component: IMMO          H21 0320  
   Serial number:               
   Coding: 000000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03008
   ROD: EV_Immo_UDS_VDD_RM09_VW21.rod
   VCID: 6ADB896E8D14871634-803E

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist        Labels: 6Q0-423-156.clb
   Part No: 6R0 423 156 B
   Component: LenkhilfeTRW        V277  
   Coding: 11230
   Shop #: WSC 31414  
   VCID: 2F6D587AEA76223E23-807A

No fault code found.

-------------------------------------------------------------------------------
Address 55: Headlight Range (J431)       Labels:. 6R0-907-357.clb
   Part No SW: 6R0 907 357     HW: 6R0 907 357 
   Component: LWR-ECU       H02 0070  
   Revision: --------    Serial number: --------------
   Coding: 0114000001000000
   Shop #: WSC 12345 123 12345
   ASAM Dataset: EV_HeadlRegulVWLWRPt 001004
   ROD: EV_HeadlRegulVWLWRPt_VW25.rod
   VCID: 77FDA01ACEA62AFEBB-8022

4 Faults Found:
12583424 - Databus 
          U1201 00 [008] - No Communications
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 2
                    Reset counter: 55
                    Mileage: 100298 km
                    Date: 2017.10.23
                    Time: 16:46:14

13705472 - Databus 
          U1121 00 [008] - Missing Message
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 1
                    Reset counter: 55
                    Mileage: 100298 km
                    Date: 2017.10.23
                    Time: 16:46:13

13705474 - Databus 
          U1121 00 [008] - Missing Message
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 1
                    Reset counter: 55
                    Mileage: 100298 km
                    Date: 2017.10.23
                    Time: 16:46:13

13705475 - Databus 
          U1121 00 [008] - Missing Message
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 1
                    Reset counter: 55
                    Mileage: 100298 km
                    Date: 2017.10.23
                    Time: 16:46:13


-------------------------------------------------------------------------------
Address 56: Radio
Cannot be reached

End-------------------------(Elapsed Time: 02:54)--------------------------
Hope to hear from u soon. :o
Last edited by numberior on Mon Oct 23, 2017 10:25 am, edited 1 time in total.
numberior
New
Posts: 43
Joined: Thu Sep 21, 2017 3:34 pm
Drives: Polo GTI 6r
Location: Singapore

Re: numberior´s 2011 Polo 6R GTI DSG

Post by numberior »

numberior wrote: Thu Oct 19, 2017 5:34 pm Hi Ciclo,
Yes, there is some difference in the wires reaching the Light switch/Dimmer connectors.
- Blue / Gray = Yellow / Gray (T17 connector, and T6 connector)
- You must also remove/isolate the T17/6 original wire.

---
I left out T17/6.
Will get to doing it.....just thought I tell you in case it's causing the error. :roll:
I've done it by the way.
numberior
New
Posts: 43
Joined: Thu Sep 21, 2017 3:34 pm
Drives: Polo GTI 6r
Location: Singapore

Re: numberior´s 2011 Polo 6R GTI DSG

Post by numberior »

I moved AFS supply to switched 12V.
And it instantly worked.

:P

Code: Select all

Monday,23,October,2017,18:16:29:27502
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64
VCDS Version: 17.8.0.1 (x64)
Data version: 20170721 DS276.2
www.Ross-Tech.com


VIN: WVWZZZ6RZBY312116   License Plate: 13TH SCAN
Mileage: 100290km-62317mi   Repair Order: 



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 6R-VW25 (7E0)
Scan: 01 02 03 04 08 09 15 17 19 25 44 55 56 0B

VIN: WVWZZZ6RZBY312116   Mileage: 100290km-62317miles

01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: Cannot be reached 1100
 
-------------------------------------------------------------------------------
Address 01: Engine        Labels:. 03C-907-309-V1.clb
   Part No SW: 03C 906 027 AR    HW: 03C 906 027 AR
   Component: 1.4l R4 TSI   H15 9971  
   Revision: L2H15---    Serial number: 00000000000000
   Shop #: WSC 12345 123 12345
   ASAM Dataset: EV_ECM14TSI01103C906027AR 001014
   ROD: EV_ECM14TSI01103C906027AR.rod
   VCID: 71E99E02A0C274CE75-8024

No fault code found.
Readiness: 0010 0101

-------------------------------------------------------------------------------
Address 02: Auto Trans
Cannot be reached

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels:. 6R0-907-37x-ESP82.clb
   Part No SW: 6R0 907 379 AK    HW: 6R0 907 379 AF
   Component: ESP8.2i front H05 0001  
   Revision: --------    
   Coding: 230248E3416E02B4C42612E382D740811700
   Shop #: WSC 00788 648 00255
   VCID: 071DD0DAB2465A7ECB-8052

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels: 6R0-907-044.clb
   Part No SW: 6R0 907 044 E    HW: 6R0 907 044 E
   Component: Climatronic   H09 0609  
   Revision: V0000000    
   VCID: 35616A129C2A18EE69-8060

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:. 7E0-937-BCM-V1.clb
   Part No SW: 7E0 937 090 B    HW: 7E0 937 090 
   Component: BCM PQ25 Max4 H81 0744  
   Revision: B9081001    Serial number: 0982 321160318
   Coding: 3CB02BBF08A1000008380C916C2B0CD05AC0670F60051040200000030000
   Shop #: WSC 12345 123 12345
   VCID: 2A5B496E45944716F4-807E

   Subsystem 1 - Part No SW: 6R0 959 802 AB    HW: 6R0 959 802 AB  Labels: 6R0-959-802.CLB
   Component: J386__TSG_FT  007 1611 
   Serial number: KU0KU024031100012688
   Coding: 18BC30

   Subsystem 2 - Part No SW: 6R0 959 801 AD    HW: 6R0 959 801 AD  Labels: 6R0-959-801.CLB
   Component: J387__TSG_BT  007 1611 
   Serial number: KU0KU016031100015781
   Coding: 08BC30

   Subsystem 3 - Part No SW: 6R0 959 591 A    HW: 7P0 959 591 
   Component: J245 PS72.015  H05 0006 
   Serial number:     WOO1165901/     
   Coding: 081001

   Subsystem 4 - Part No SW: 5K0 959 542     HW: 5K0 959 542 
   Component: E221__MFL-TAS  H05 0010 
   Serial number: 0050759             
   Coding: 830000

   Subsystem 5 - Part No SW: 6R0 959 811 G    HW: 6R0 959 811 G
   Component: J388__TSG_HL  007 1611 
   Serial number: KU0KU011041100017315
   Coding: 08BC32

   Subsystem 6 - Part No SW: 6R0 959 812 G    HW: 6R0 959 812 G
   Component: J389__TSG_HR  007 1611 
   Serial number: KU0KU011041100013053
   Coding: 08BC32

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels:| 5K0-959-655.clb
   Part No SW: 6R0 959 655 M    HW: 6R0 959 655 M
   Component: VW10Airbag01E H09 0020  
   Revision: --------    Serial number: 003GZ000HCNK
   Coding: 003145
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_AirbaVW10BPAVW250 A01001
   ROD: EV_AirbaVW10BPAVW250_VW25.rod
   VCID: 4C972FF6E7A0792626-8018

   Crash sensor for side airbag: driver side: 
   Serial number: 3575HRB40550HJHG9ON%

   Crash sensor for side airbag: front passenger side: 
   Serial number: 3585HRB40590HJHG919A

   Crash sensor for side airbag: rear: driver side: 
   Serial number: 3515RRB405B0I4AG6OGL

   Crash sensor for side airbag: rear: passenger side: 
   Serial number: 3525RRB404R0H4DUHPLR

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 5K0-920-xxx-17.clb
   Part No SW: 6R0 920 870     HW: 6R0 920 870 
   Component: KOMBI         H21 0320  
   Serial number: 00000000000000
   Coding: 140A00
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04086
   ROD: EV_Kombi_UDS_VDD_RM09_A04_VW25.rod
   VCID: 72EB910EA5C44FD68C-8026

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels:. 7E0-909-901.clb
   Part No SW: 7E0 909 901     HW: 7E0 937 090 
   Component: GW-K-CAN TP20 H81 0744  
   Revision: B9081001    
   Coding: 002300
   Shop #: WSC 12345 123 12345
   VCID: 68DFF3669B18B50622-803C

1 Fault Found:
01304 - Radio 
            004 - No Signal/Communication
             Freeze Frame:
                    Fault Status: 01100100
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 10
                    Mileage: 100245 km
                    Time Indication: 0
                    Date: 2012.03.13
                    Time: 23:57:39


-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels:| 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5K0 953 234 
   Component: IMMO          H21 0320  
   Serial number:               
   Coding: 000000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03008
   ROD: EV_Immo_UDS_VDD_RM09_VW21.rod
   VCID: 6ADB896E8D14871634-803E

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist        Labels: 6Q0-423-156.clb
   Part No: 6R0 423 156 B
   Component: LenkhilfeTRW        V277  
   Coding: 11230
   Shop #: WSC 31414  
   VCID: 2F6D587AEA76223E23-807A

No fault code found.

-------------------------------------------------------------------------------
Address 55: Headlight Range (J431)       Labels:. 6R0-907-357.clb
   Part No SW: 6R0 907 357     HW: 6R0 907 357 
   Component: LWR-ECU       H02 0070  
   Revision: --------    Serial number: --------------
   Coding: 0114000001000000
   Shop #: WSC 12345 123 12345
   ASAM Dataset: EV_HeadlRegulVWLWRPt 001004
   ROD: EV_HeadlRegulVWLWRPt_VW25.rod
   VCID: 77FDA01ACEA62AFEBB-8022

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio
Cannot be reached

End-------------------------(Elapsed Time: 02:55)--------------------------
Thanks for all the help here.
Especially the BIG HELP extended by Cilco!
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7786
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: numberior´s 2011 Polo 6R GTI DSG

Post by ciclo »

numberior
New
Posts: 43
Joined: Thu Sep 21, 2017 3:34 pm
Drives: Polo GTI 6r
Location: Singapore

Re: numberior´s 2011 Polo 6R GTI DSG

Post by numberior »

ciclo wrote: Mon Oct 23, 2017 11:50 am As you can see in the following image the headlights range control module (J431) is powered by fuse nº11, which receives power after turning the ignition key, +15.
https://drive.google.com/file/d/0B2nv91 ... sp=sharing

... in the following image you can clearly see that +15 is the +ve signal assigned for fuse nº11.
https://drive.google.com/file/d/0B2nv91 ... sp=sharing


I'm glad that everything works now, enjoy it, you deserve it. 8)


Check out these links, maybe some useful for you :) :

http://www.uk-polos.net/viewtopic.php?f ... 05#p474349
http://www.uk-polos.net/viewtopic.php?f ... 95#p477710
http://www.uk-polos.net/viewtopic.php?f ... 65#p491539
http://www.uk-polos.net/viewtopic.php?f ... 65#p491577
http://www.uk-polos.net/viewtopic.php?f ... 30#p504328
http://www.uk-polos.net/viewtopic.php?f ... 82#p517482
http://www.uk-polos.net/viewtopic.php?f ... 15#p517604
http://www.uk-polos.net/viewtopic.php?f ... 20#p518296
http://www.uk-polos.net/viewtopic.php?f ... 20#p518219
http://www.uk-polos.net/viewtopic.php?f ... 80#p520980
Thanks for your explanation on the terminals Ciclo....

@ the end of it, the result justifies all the hard work.
The cornering lights feature is fantastic.

Also those VCDS tweaks will so bring out the BCM Max :twisted: They'll be on my to-do list.
Last edited by numberior on Mon Oct 23, 2017 3:03 pm, edited 1 time in total.
numberior
New
Posts: 43
Joined: Thu Sep 21, 2017 3:34 pm
Drives: Polo GTI 6r
Location: Singapore

Re: numberior´s 2011 Polo 6R GTI DSG

Post by numberior »

Hi Ciclo,
My lamps are working fine now.
As you know, I'm waiting for halogen bulbs to come in to replace the existing LED bulbs I use for cornering lights.
So I would expect errors(if any) from cornering lights.

However, errors are captured in BCM module when I activate high beam.
The code brings out "M30" and "M32", which are high beam bulbs bulbs in halogen headlights.
Is this intended, in the case of retrofit?
There's no error when cornering lights are activated.

That means to the BCM, cornering lights= high beam and vice versa?

Code: Select all

2 Faults Found:
01495 - Bulb for High-Beams; Left (M30) 
            010 - Open or Short to Plus
             Freeze Frame:
                    Fault Status: 01101010
                    Fault Priority: 3
                    Fault Frequency: 1
                    Reset counter: 10
                    Mileage: 100245 km
                    Time Indication: 0
                    Date: 2012.03.14
                    Time: 00:12:04

01499 - Bulb for High-Beams; Right (M32) 
            010 - Open or Short to Plus
             Freeze Frame:
                    Fault Status: 01101010
                    Fault Priority: 3
                    Fault Frequency: 1
                    Reset counter: 10
                    Mileage: 100245 km
                    Time Indication: 0
                    Date: 2012.03.14
                    Time: 00:12:04
numberior
New
Posts: 43
Joined: Thu Sep 21, 2017 3:34 pm
Drives: Polo GTI 6r
Location: Singapore

Re: numberior´s 2011 Polo 6R GTI DSG

Post by numberior »

For those interested in WRC look........
My Polo 6R, with newly fitted WRC front bumper and bi-xenon headlamps.
Image
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7786
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: numberior´s 2011 Polo 6R GTI DSG

Post by ciclo »

numberior wrote: Mon Oct 23, 2017 1:57 pm Hi Ciclo,
My lamps are working fine now.
As you know, I'm waiting for halogen bulbs to come in to replace the existing LED bulbs I use for cornering lights.
So I would expect errors(if any) from cornering lights.

However, errors are captured in BCM module when I activate high beam.
The code brings out "M30" and "M32", which are high beam bulbs bulbs in halogen headlights.
Is this intended, in the case of retrofit?
There's no error when cornering lights are activated.

That means to the BCM, cornering lights= high beam and vice versa?

Code: Select all

2 Faults Found:
01495 - Bulb for High-Beams; Left (M30) 
            010 - Open or Short to Plus
             Freeze Frame:
                    Fault Status: 01101010
                    Fault Priority: 3
                    Fault Frequency: 1
                    Reset counter: 10
                    Mileage: 100245 km
                    Time Indication: 0
                    Date: 2012.03.14
                    Time: 00:12:04

01499 - Bulb for High-Beams; Right (M32) 
            010 - Open or Short to Plus
             Freeze Frame:
                    Fault Status: 01101010
                    Fault Priority: 3
                    Fault Frequency: 1
                    Reset counter: 10
                    Mileage: 100245 km
                    Time Indication: 0
                    Date: 2012.03.14
                    Time: 00:12:04
:lol:... Something odd is happening here.

Do this :arrow: https://drive.google.com/drive/folders/ ... sp=sharing

... and post a link so I can download your BCM adaptation channels log.
numberior wrote: Mon Oct 23, 2017 3:00 pm For those interested in WRC look........
My Polo 6R, with newly fitted WRC front bumper and bi-xenon headlamps.
[img]https://i.imgur.com/C48JjKy.jpg[/img
wow!!! 8)
numberior
New
Posts: 43
Joined: Thu Sep 21, 2017 3:34 pm
Drives: Polo GTI 6r
Location: Singapore

Re: numberior´s 2011 Polo 6R GTI DSG

Post by numberior »

Here is it Cilco: :o

https://drive.google.com/file/d/0B7xS6r ... sp=sharing

Latest autoscan:

Code: Select all

Tuesday,24,October,2017,12:59:34:27502
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64
VCDS Version: 17.8.0.1 (x64)
Data version: 20170721 DS276.2
www.Ross-Tech.com


VIN: WVWZZZ6RZBY312116   License Plate: 14TH SCAN
Mileage: 100340km-62348mi   Repair Order: 



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 6R-VW25 (7E0)
Scan: 01 02 03 04 08 09 15 17 19 25 44 55 56 0B

VIN: WVWZZZ6RZBY312116   Mileage: 100340km-62348miles

01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: Cannot be reached 1100
 
-------------------------------------------------------------------------------
Address 01: Engine (J623-CAVE)       Labels:. 03C-907-309-V1.clb
   Part No SW: 03C 906 027 AR    HW: 03C 906 027 AR
   Component: 1.4l R4 TSI   H15 9971  
   Revision: L2H15---    Serial number: 00000000000000
   Coding: 00250012002400000000
   Shop #: WSC 12345 123 12345
   ASAM Dataset: EV_ECM14TSI01103C906027AR 001014
   ROD: EV_ECM14TSI01103C906027AR.rod
   VCID: 71E99E02A0C274CE75-8024

No fault code found.
Readiness: 0000 0101

-------------------------------------------------------------------------------
Address 02: Auto Trans
Cannot be reached

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels:. 6R0-907-37x-ESP82.clb
   Part No SW: 6R0 907 379 AK    HW: 6R0 907 379 AF
   Component: ESP8.2i front H05 0001  
   Revision: --------    
   Coding: 230248E3416E02B4C42612E382D740811700
   Shop #: WSC 00788 648 00255
   VCID: 071DD0DAB2465A7ECB-8052

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels: 6R0-907-044.clb
   Part No SW: 6R0 907 044 E    HW: 6R0 907 044 E
   Component: Climatronic   H09 0609  
   Revision: V0000000    
   VCID: 35616A129C2A18EE69-8060

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:. 7E0-937-BCM-V1.clb
   Part No SW: 7E0 937 090 B    HW: 7E0 937 090 
   Component: BCM PQ25 Max4 H81 0744  
   Revision: B9081001    Serial number: 0982 321160318
   Coding: 3CB02BBF08A1000008380C916C2B0CD05AC0670F60051040200000030000
   Shop #: WSC 12345 123 12345
   VCID: 2A5B496E45944716F4-807E

   Subsystem 1 - Part No SW: 6R0 959 802 AB    HW: 6R0 959 802 AB  Labels: 6R0-959-802.CLB
   Component: J386__TSG_FT  007 1611 
   Serial number: KU0KU024031100012688
   Coding: 18BC30

   Subsystem 2 - Part No SW: 6R0 959 801 AD    HW: 6R0 959 801 AD  Labels: 6R0-959-801.CLB
   Component: J387__TSG_BT  007 1611 
   Serial number: KU0KU016031100015781
   Coding: 08BC30

   Subsystem 3 - Part No SW: 6R0 959 591 A    HW: 7P0 959 591 
   Component: J245 PS72.015  H05 0006 
   Serial number:     WOO1165901/     
   Coding: 081001

   Subsystem 4 - Part No SW: 5K0 959 542     HW: 5K0 959 542 
   Component: E221__MFL-TAS  H05 0010 
   Serial number: 0050759             
   Coding: 830000

   Subsystem 5 - Part No SW: 6R0 959 811 G    HW: 6R0 959 811 G
   Component: J388__TSG_HL  007 1611 
   Serial number: KU0KU011041100017315
   Coding: 08BC32

   Subsystem 6 - Part No SW: 6R0 959 812 G    HW: 6R0 959 812 G
   Component: J389__TSG_HR  007 1611 
   Serial number: KU0KU011041100013053
   Coding: 08BC32

2 Faults Found:
01495 - Bulb for High-Beams; Left (M30) 
            010 - Open or Short to Plus
             Freeze Frame:
                    Fault Status: 01101010
                    Fault Priority: 3
                    Fault Frequency: 1
                    Reset counter: 15
                    Mileage: 100300 km
                    Time Indication: 0
                    Date: 2012.03.15
                    Time: 19:35:47

01499 - Bulb for High-Beams; Right (M32) 
            010 - Open or Short to Plus
             Freeze Frame:
                    Fault Status: 01101010
                    Fault Priority: 3
                    Fault Frequency: 1
                    Reset counter: 15
                    Mileage: 100300 km
                    Time Indication: 0
                    Date: 2012.03.15
                    Time: 19:35:47


-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels:| 5K0-959-655.clb
   Part No SW: 6R0 959 655 M    HW: 6R0 959 655 M
   Component: VW10Airbag01E H09 0020  
   Revision: --------    Serial number: 003GZ000HCNK
   Coding: 003145
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_AirbaVW10BPAVW250 A01001
   ROD: EV_AirbaVW10BPAVW250_VW25.rod
   VCID: 4C972FF6E7A0792626-8018

   Crash sensor for side airbag: driver side: 
   Serial number: 3575HRB40550HJHG9ON%

   Crash sensor for side airbag: front passenger side: 
   Serial number: 3585HRB40590HJHG919A

   Crash sensor for side airbag: rear: driver side: 
   Serial number: 3515RRB405B0I4AG6OGL

   Crash sensor for side airbag: rear: passenger side: 
   Serial number: 3525RRB404R0H4DUHPLR

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 5K0-920-xxx-17.clb
   Part No SW: 6R0 920 870     HW: 6R0 920 870 
   Component: KOMBI         H21 0320  
   Serial number: 00000000000000
   Coding: 140A00
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04086
   ROD: EV_Kombi_UDS_VDD_RM09_A04_VW25.rod
   VCID: 72EB910EA5C44FD68C-8026

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels:. 7E0-909-901.clb
   Part No SW: 7E0 909 901     HW: 7E0 937 090 
   Component: GW-K-CAN TP20 H81 0744  
   Revision: B9081001    
   Coding: 002300
   Shop #: WSC 12345 123 12345
   VCID: 68DFF3669B18B50622-803C

1 Fault Found:
01304 - Radio 
            004 - No Signal/Communication
             Freeze Frame:
                    Fault Status: 01100100
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 10
                    Mileage: 100245 km
                    Time Indication: 0
                    Date: 2012.03.13
                    Time: 23:57:39


-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels:| 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5K0 953 234 
   Component: IMMO          H21 0320  
   Serial number:               
   Coding: 000000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03008
   ROD: EV_Immo_UDS_VDD_RM09_VW21.rod
   VCID: 6ADB896E8D14871634-803E

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist        Labels: 6Q0-423-156.clb
   Part No: 6R0 423 156 B
   Component: LenkhilfeTRW        V277  
   Coding: 11230
   Shop #: WSC 31414  
   VCID: 2F6D587AEA76223E23-807A

No fault code found.

-------------------------------------------------------------------------------
Address 55: Headlight Range (J431)       Labels:. 6R0-907-357.clb
   Part No SW: 6R0 907 357     HW: 6R0 907 357 
   Component: LWR-ECU       H02 0070  
   Revision: --------    Serial number: --------------
   Coding: 0114000001000000
   Shop #: WSC 12345 123 12345
   ASAM Dataset: EV_HeadlRegulVWLWRPt 001004
   ROD: EV_HeadlRegulVWLWRPt_VW25.rod
   VCID: 77FDA01ACEA62AFEBB-8022

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio
Cannot be reached

End-------------------------(Elapsed Time: 03:03)--------------------------
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7786
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: numberior´s 2011 Polo 6R GTI DSG

Post by ciclo »

The BCM adaptation channels appear to be correct according to VCDS reading.

TESTS:

Current BCM coding
3CB02BBF08A1000008380C916C2B0CD05AC0670F60051040200000030000

Try with these BCM codings
1st
3CB02BBF08A1000008380C916C2B0CD05AC0470F60051040200000030000
check for faults

2nd
3CB02BBF08A1000008380C916C2B0CD0DAC0470F60051040200000030000
check for faults

3rd
3CB02BBF08A1000008380C916C2B0CD0D2C0470F60051040200000030000
check for faults

By the way, all of the above is by assuming your high beams are working correctly despite the faults. According to your electrical installation the BCM does not have a diagnostic control over the highbeam lamps, it only controls the switching (lowbeam/highbeam) to activate the shutters (T73a/62).

What is the donor car of your 7E0 BCM? Where did you buy this 7E0 BCM? Do you have its PR-codes?
Post Reply