Page 4 of 6
Re: numberior´s 2011 Polo 6R GTI DSG
Posted: Tue Oct 24, 2017 2:46 pm
by numberior
ciclo wrote: ↑Tue Oct 24, 2017 11:58 am
The BCM adaptation channels appear to be correct according to VCDS reading.
TESTS:
Current BCM coding
3CB02BBF08A1000008380C916C2B0CD05AC0670F60051040200000030000
Try with these BCM codings
1st
3CB02BBF08A1000008380C916C2B0CD05AC0470F60051040200000030000
check for faults
2nd
3CB02BBF08A1000008380C916C2B0CD0DAC0470F60051040200000030000
check for faults
3rd
3CB02BBF08A1000008380C916C2B0CD0D2C0470F60051040200000030000
check for faults
By the way, all of the above is by assuming your high beams are working correctly despite the faults. According to your electrical installation the BCM does not have a diagnostic control over the highbeam lamps, it only controls the switching (lowbeam/highbeam) to activate the shutters (T73a/62).
What is the donor car of your 7E0 BCM? Where did you buy this 7E0 BCM? Do you have its PR-codes?
Hi Ciclo,
I bought it on ebay:
http://www.ebay.com.sg/itm/Polo-Caravel ... 2749.l2649
These are from my BCM Max. Will it help?
It was listed as new, looks new and factory state was enabled.
I'm going to try out the BCM codes in a while.
Will report back soon.
Re: numberior´s 2011 Polo 6R GTI DSG
Posted: Tue Oct 24, 2017 4:22 pm
by numberior
Hi Ciclo,
I've tested the codes.
For each of them:
I cleared all DTCs.
Entered BCM coding.
Performed autoscan.
Activated high beam.
1st
3CB02BBF08A1000008380C916C2B0CD05AC0470F60051040200000030000
Code: Select all
Tuesday,24,October,2017,22:44:13:27502
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64
VCDS Version: 17.8.0.1 (x64)
Data version: 20170721 DS276.2
www.Ross-Tech.com
VIN: WVWZZZ6RZBY312116 License Plate: 15TH SCAN-1ST TEST
Mileage: 100380km-62373mi Repair Order:
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: 6R-VW25 (7E0)
Scan: 01 02 03 04 08 09 15 17 19 25 44 55 56 0B
VIN: WVWZZZ6RZBY312116 Mileage: 100380km-62373miles
01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: Cannot be reached 1100
-------------------------------------------------------------------------------
Address 01: Engine (J623-CAVE) Labels:. 03C-907-309-V1.clb
Part No SW: 03C 906 027 AR HW: 03C 906 027 AR
Component: 1.4l R4 TSI H15 9971
Revision: L2H15--- Serial number: 00000000000000
Coding: 00250012002400000000
Shop #: WSC 12345 123 12345
ASAM Dataset: EV_ECM14TSI01103C906027AR 001014
ROD: EV_ECM14TSI01103C906027AR.rod
VCID: 71E99E02A0C274CE75-8024
No fault code found.
Readiness: 0000 0101
-------------------------------------------------------------------------------
Address 02: Auto Trans
Cannot be reached
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels:. 6R0-907-37x-ESP82.clb
Part No SW: 6R0 907 379 AK HW: 6R0 907 379 AF
Component: ESP8.2i front H05 0001
Revision: --------
Coding: 230248E3416E02B4C42612E382D740811700
Shop #: WSC 00788 648 00255
VCID: 071DD0DAB2465A7ECB-8052
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels: 6R0-907-044.clb
Part No SW: 6R0 907 044 E HW: 6R0 907 044 E
Component: Climatronic H09 0609
Revision: V0000000
VCID: 35616A129C2A18EE69-8060
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 7E0-937-BCM-V1.clb
Part No SW: 7E0 937 090 B HW: 7E0 937 090
Component: BCM PQ25 Max4 H81 0744
Revision: B9081001 Serial number: 0982 321160318
Coding: 3CB02BBF08A1000008380C916C2B0CD05AC0470F60051040200000030000
Shop #: WSC 12345 123 12345
VCID: 2A5B496E45944716F4-807E
Subsystem 1 - Part No SW: 6R0 959 802 AB HW: 6R0 959 802 AB Labels: 6R0-959-802.CLB
Component: J386__TSG_FT 007 1611
Serial number: KU0KU024031100012688
Coding: 18BC30
Subsystem 2 - Part No SW: 6R0 959 801 AD HW: 6R0 959 801 AD Labels: 6R0-959-801.CLB
Component: J387__TSG_BT 007 1611
Serial number: KU0KU016031100015781
Coding: 08BC30
Subsystem 3 - Part No SW: 6R0 959 591 A HW: 7P0 959 591
Component: J245 PS72.015 H05 0006
Serial number: WOO1165901/
Coding: 081001
Subsystem 4 - Part No SW: 5K0 959 542 HW: 5K0 959 542
Component: E221__MFL-TAS H05 0010
Serial number: 0050759
Coding: 830000
Subsystem 5 - Part No SW: 6R0 959 811 G HW: 6R0 959 811 G
Component: J388__TSG_HL 007 1611
Serial number: KU0KU011041100017315
Coding: 08BC32
Subsystem 6 - Part No SW: 6R0 959 812 G HW: 6R0 959 812 G
Component: J389__TSG_HR 007 1611
Serial number: KU0KU011041100013053
Coding: 08BC32
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:| 5K0-959-655.clb
Part No SW: 6R0 959 655 M HW: 6R0 959 655 M
Component: VW10Airbag01E H09 0020
Revision: -------- Serial number: 003GZ000HCNK
Coding: 003145
Shop #: WSC 00788 648 00255
ASAM Dataset: EV_AirbaVW10BPAVW250 A01001
ROD: EV_AirbaVW10BPAVW250_VW25.rod
VCID: 4C972FF6E7A0792626-8018
Crash sensor for side airbag: driver side:
Serial number: 3575HRB40550HJHG9ON%
Crash sensor for side airbag: front passenger side:
Serial number: 3585HRB40590HJHG919A
Crash sensor for side airbag: rear: driver side:
Serial number: 3515RRB405B0I4AG6OGL
Crash sensor for side airbag: rear: passenger side:
Serial number: 3525RRB404R0H4DUHPLR
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5K0-920-xxx-17.clb
Part No SW: 6R0 920 870 HW: 6R0 920 870
Component: KOMBI H21 0320
Serial number: 00000000000000
Coding: 140A00
Shop #: WSC 00788 648 00255
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04086
ROD: EV_Kombi_UDS_VDD_RM09_A04_VW25.rod
VCID: 72EB910EA5C44FD68C-8026
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 7E0-909-901.clb
Part No SW: 7E0 909 901 HW: 7E0 937 090
Component: GW-K-CAN TP20 H81 0744
Revision: B9081001
Coding: 002300
Shop #: WSC 12345 123 12345
VCID: 68DFF3669B18B50622-803C
1 Fault Found:
01304 - Radio
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 10
Mileage: 100245 km
Time Indication: 0
Date: 2012.03.13
Time: 23:57:39
-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels:| 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H21 0320
Serial number:
Coding: 000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03008
ROD: EV_Immo_UDS_VDD_RM09_VW21.rod
VCID: 6ADB896E8D14871634-803E
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 6Q0-423-156.clb
Part No: 6R0 423 156 B
Component: LenkhilfeTRW V277
Coding: 11221
Shop #: WSC 31414
VCID: 2F6D587AEA76223E23-807A
No fault code found.
-------------------------------------------------------------------------------
Address 55: Headlight Range (J431) Labels:. 6R0-907-357.clb
Part No SW: 6R0 907 357 HW: 6R0 907 357
Component: LWR-ECU H02 0070
Revision: -------- Serial number: --------------
Coding: 0114000001000000
Shop #: WSC 12345 123 12345
ASAM Dataset: EV_HeadlRegulVWLWRPt 001004
ROD: EV_HeadlRegulVWLWRPt_VW25.rod
VCID: 77FDA01ACEA62AFEBB-8022
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio
Cannot be reached
End-------------------------(Elapsed Time: 03:02)--------------------------
2nd
3CB02BBF08A1000008380C916C2B0CD0DAC0470F60051040200000030000
Code: Select all
Tuesday,24,October,2017,22:50:31:27502
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64
VCDS Version: 17.8.0.1 (x64)
Data version: 20170721 DS276.2
www.Ross-Tech.com
VIN: WVWZZZ6RZBY312116 License Plate:
Mileage: 100380km-62373mi Repair Order:
Chassis Type: 6R-VW25 (7E0)
Scan: 01 02 03 04 08 09 15 17 19 25 44 55 56 0B
VIN: WVWZZZ6RZBY312116 Mileage: 100380km-62373miles
01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: Cannot be reached 1100
-------------------------------------------------------------------------------
Address 01: Engine (J623-CAVE) Labels:. 03C-907-309-V1.clb
Part No SW: 03C 906 027 AR HW: 03C 906 027 AR
Component: 1.4l R4 TSI H15 9971
Revision: L2H15--- Serial number: 00000000000000
Coding: 00250012002400000000
Shop #: WSC 12345 123 12345
ASAM Dataset: EV_ECM14TSI01103C906027AR 001014
ROD: EV_ECM14TSI01103C906027AR.rod
VCID: 71E99E02A0C274CE75-8024
No fault code found.
Readiness: 0000 0101
-------------------------------------------------------------------------------
Address 02: Auto Trans
Cannot be reached
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels:. 6R0-907-37x-ESP82.clb
Part No SW: 6R0 907 379 AK HW: 6R0 907 379 AF
Component: ESP8.2i front H05 0001
Revision: --------
Coding: 230248E3416E02B4C42612E382D740811700
Shop #: WSC 00788 648 00255
VCID: 071DD0DAB2465A7ECB-8052
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels: 6R0-907-044.clb
Part No SW: 6R0 907 044 E HW: 6R0 907 044 E
Component: Climatronic H09 0609
Revision: V0000000
VCID: 35616A129C2A18EE69-8060
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 7E0-937-BCM-V1.clb
Part No SW: 7E0 937 090 B HW: 7E0 937 090
Component: BCM PQ25 Max4 H81 0744
Revision: B9081001 Serial number: 0982 321160318
Coding: 3CB02BBF08A1000008380C916C2B0CD0DAC0470F60051040200000030000
Shop #: WSC 12345 123 12345
VCID: 2A5B496E45944716F4-807E
Subsystem 1 - Part No SW: 6R0 959 802 AB HW: 6R0 959 802 AB Labels: 6R0-959-802.CLB
Component: J386__TSG_FT 007 1611
Serial number: KU0KU024031100012688
Coding: 18BC30
Subsystem 2 - Part No SW: 6R0 959 801 AD HW: 6R0 959 801 AD Labels: 6R0-959-801.CLB
Component: J387__TSG_BT 007 1611
Serial number: KU0KU016031100015781
Coding: 08BC30
Subsystem 3 - Part No SW: 6R0 959 591 A HW: 7P0 959 591
Component: J245 PS72.015 H05 0006
Serial number: WOO1165901/
Coding: 081001
Subsystem 4 - Part No SW: 5K0 959 542 HW: 5K0 959 542
Component: E221__MFL-TAS H05 0010
Serial number: 0050759
Coding: 830000
Subsystem 5 - Part No SW: 6R0 959 811 G HW: 6R0 959 811 G
Component: J388__TSG_HL 007 1611
Serial number: KU0KU011041100017315
Coding: 08BC32
Subsystem 6 - Part No SW: 6R0 959 812 G HW: 6R0 959 812 G
Component: J389__TSG_HR 007 1611
Serial number: KU0KU011041100013053
Coding: 08BC32
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:| 5K0-959-655.clb
Part No SW: 6R0 959 655 M HW: 6R0 959 655 M
Component: VW10Airbag01E H09 0020
Revision: -------- Serial number: 003GZ000HCNK
Coding: 003145
Shop #: WSC 00788 648 00255
ASAM Dataset: EV_AirbaVW10BPAVW250 A01001
ROD: EV_AirbaVW10BPAVW250_VW25.rod
VCID: 4C972FF6E7A0792626-8018
Crash sensor for side airbag: driver side:
Serial number: 3575HRB40550HJHG9ON%
Crash sensor for side airbag: front passenger side:
Serial number: 3585HRB40590HJHG919A
Crash sensor for side airbag: rear: driver side:
Serial number: 3515RRB405B0I4AG6OGL
Crash sensor for side airbag: rear: passenger side:
Serial number: 3525RRB404R0H4DUHPLR
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5K0-920-xxx-17.clb
Part No SW: 6R0 920 870 HW: 6R0 920 870
Component: KOMBI H21 0320
Serial number: 00000000000000
Coding: 140A00
Shop #: WSC 00788 648 00255
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04086
ROD: EV_Kombi_UDS_VDD_RM09_A04_VW25.rod
VCID: 72EB910EA5C44FD68C-8026
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 7E0-909-901.clb
Part No SW: 7E0 909 901 HW: 7E0 937 090
Component: GW-K-CAN TP20 H81 0744
Revision: B9081001
Coding: 002300
Shop #: WSC 12345 123 12345
VCID: 68DFF3669B18B50622-803C
1 Fault Found:
01304 - Radio
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 10
Mileage: 100245 km
Time Indication: 0
Date: 2012.03.13
Time: 23:57:39
-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels:| 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H21 0320
Serial number:
Coding: 000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03008
ROD: EV_Immo_UDS_VDD_RM09_VW21.rod
VCID: 6ADB896E8D14871634-803E
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 6Q0-423-156.clb
Part No: 6R0 423 156 B
Component: LenkhilfeTRW V277
Coding: 11221
Shop #: WSC 31414
VCID: 2F6D587AEA76223E23-807A
No fault code found.
-------------------------------------------------------------------------------
Address 55: Headlight Range (J431) Labels:. 6R0-907-357.clb
Part No SW: 6R0 907 357 HW: 6R0 907 357
Component: LWR-ECU H02 0070
Revision: -------- Serial number: --------------
Coding: 0114000001000000
Shop #: WSC 12345 123 12345
ASAM Dataset: EV_HeadlRegulVWLWRPt 001004
ROD: EV_HeadlRegulVWLWRPt_VW25.rod
VCID: 77FDA01ACEA62AFEBB-8022
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio
Cannot be reached
End-------------------------(Elapsed Time: 02:59)--------------------------
3rd
3CB02BBF08A1000008380C916C2B0CD0D2C0470F60051040200000030000
Code: Select all
Tuesday,24,October,2017,22:56:50:27502
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64
VCDS Version: 17.8.0.1 (x64)
Data version: 20170721 DS276.2
www.Ross-Tech.com
VIN: WVWZZZ6RZBY312116 License Plate: 17TH SCAN-3RD TEST
Mileage: 100380km-62373mi Repair Order:
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: 6R-VW25 (7E0)
Scan: 01 02 03 04 08 09 15 17 19 25 44 55 56 0B
VIN: WVWZZZ6RZBY312116 Mileage: 100380km-62373miles
01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: Cannot be reached 1100
-------------------------------------------------------------------------------
Address 01: Engine (J623-CAVE) Labels:. 03C-907-309-V1.clb
Part No SW: 03C 906 027 AR HW: 03C 906 027 AR
Component: 1.4l R4 TSI H15 9971
Revision: L2H15--- Serial number: 00000000000000
Coding: 00250012002400000000
Shop #: WSC 12345 123 12345
ASAM Dataset: EV_ECM14TSI01103C906027AR 001014
ROD: EV_ECM14TSI01103C906027AR.rod
VCID: 71E99E02A0C274CE75-8024
No fault code found.
Readiness: 0000 0101
-------------------------------------------------------------------------------
Address 02: Auto Trans
Cannot be reached
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels:. 6R0-907-37x-ESP82.clb
Part No SW: 6R0 907 379 AK HW: 6R0 907 379 AF
Component: ESP8.2i front H05 0001
Revision: --------
Coding: 230248E3416E02B4C42612E382D740811700
Shop #: WSC 00788 648 00255
VCID: 071DD0DAB2465A7ECB-8052
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels: 6R0-907-044.clb
Part No SW: 6R0 907 044 E HW: 6R0 907 044 E
Component: Climatronic H09 0609
Revision: V0000000
VCID: 35616A129C2A18EE69-8060
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 7E0-937-BCM-V1.clb
Part No SW: 7E0 937 090 B HW: 7E0 937 090
Component: BCM PQ25 Max4 H81 0744
Revision: B9081001 Serial number: 0982 321160318
Coding: 3CB02BBF08A1000008380C916C2B0CD0D2C0470F60051040200000030000
Shop #: WSC 12345 123 12345
VCID: 2A5B496E45944716F4-807E
Subsystem 1 - Part No SW: 6R0 959 802 AB HW: 6R0 959 802 AB Labels: 6R0-959-802.CLB
Component: J386__TSG_FT 007 1611
Serial number: KU0KU024031100012688
Coding: 18BC30
Subsystem 2 - Part No SW: 6R0 959 801 AD HW: 6R0 959 801 AD Labels: 6R0-959-801.CLB
Component: J387__TSG_BT 007 1611
Serial number: KU0KU016031100015781
Coding: 08BC30
Subsystem 3 - Part No SW: 6R0 959 591 A HW: 7P0 959 591
Component: J245 PS72.015 H05 0006
Serial number: WOO1165901/
Coding: 081001
Subsystem 4 - Part No SW: 5K0 959 542 HW: 5K0 959 542
Component: E221__MFL-TAS H05 0010
Serial number: 0050759
Coding: 830000
Subsystem 5 - Part No SW: 6R0 959 811 G HW: 6R0 959 811 G
Component: J388__TSG_HL 007 1611
Serial number: KU0KU011041100017315
Coding: 08BC32
Subsystem 6 - Part No SW: 6R0 959 812 G HW: 6R0 959 812 G
Component: J389__TSG_HR 007 1611
Serial number: KU0KU011041100013053
Coding: 08BC32
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:| 5K0-959-655.clb
Part No SW: 6R0 959 655 M HW: 6R0 959 655 M
Component: VW10Airbag01E H09 0020
Revision: -------- Serial number: 003GZ000HCNK
Coding: 003145
Shop #: WSC 00788 648 00255
ASAM Dataset: EV_AirbaVW10BPAVW250 A01001
ROD: EV_AirbaVW10BPAVW250_VW25.rod
VCID: 4C972FF6E7A0792626-8018
Crash sensor for side airbag: driver side:
Serial number: 3575HRB40550HJHG9ON%
Crash sensor for side airbag: front passenger side:
Serial number: 3585HRB40590HJHG919A
Crash sensor for side airbag: rear: driver side:
Serial number: 3515RRB405B0I4AG6OGL
Crash sensor for side airbag: rear: passenger side:
Serial number: 3525RRB404R0H4DUHPLR
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5K0-920-xxx-17.clb
Part No SW: 6R0 920 870 HW: 6R0 920 870
Component: KOMBI H21 0320
Serial number: 00000000000000
Coding: 140A00
Shop #: WSC 00788 648 00255
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04086
ROD: EV_Kombi_UDS_VDD_RM09_A04_VW25.rod
VCID: 72EB910EA5C44FD68C-8026
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 7E0-909-901.clb
Part No SW: 7E0 909 901 HW: 7E0 937 090
Component: GW-K-CAN TP20 H81 0744
Revision: B9081001
Coding: 002300
Shop #: WSC 12345 123 12345
VCID: 68DFF3669B18B50622-803C
1 Fault Found:
01304 - Radio
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 10
Mileage: 100245 km
Time Indication: 0
Date: 2012.03.13
Time: 23:57:39
-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels:| 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H21 0320
Serial number:
Coding: 000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03008
ROD: EV_Immo_UDS_VDD_RM09_VW21.rod
VCID: 6ADB896E8D14871634-803E
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 6Q0-423-156.clb
Part No: 6R0 423 156 B
Component: LenkhilfeTRW V277
Coding: 11221
Shop #: WSC 31414
VCID: 2F6D587AEA76223E23-807A
No fault code found.
-------------------------------------------------------------------------------
Address 55: Headlight Range (J431) Labels:. 6R0-907-357.clb
Part No SW: 6R0 907 357 HW: 6R0 907 357
Component: LWR-ECU H02 0070
Revision: -------- Serial number: --------------
Coding: 0114000001000000
Shop #: WSC 12345 123 12345
ASAM Dataset: EV_HeadlRegulVWLWRPt 001004
ROD: EV_HeadlRegulVWLWRPt_VW25.rod
VCID: 77FDA01ACEA62AFEBB-8022
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio
Cannot be reached
End-------------------------(Elapsed Time: 03:02)--------------------------
All of your 3 test codes seem to have solved the high beam bulb error.
Then I reverted to the original coding: 3CB02BBF08A1000008380C916C2B0CD05AC0670F60051040200000030000
Error came back instantly.
Currently I'm on the 1st test code.
Thank you for your help!
Re: numberior´s 2011 Polo 6R GTI DSG
Posted: Tue Oct 24, 2017 7:17 pm
by ciclo
VIN: WVWZZZ6RZBY312116 License Plate:
17TH SCAN-3RD TEST .................
Excellent! a new discovery in the fantastic world of BCM PQ25. (with 7H0 BCMs this would not have happened)
The 1st it's perfect.
--------
Now,
New BCM coding:
3CB02BBF08A1000008380C916C6B0CD05AC0470F60053040200000030000
Check the Coming Home function through bixenon (without RLS).
- ignition off (key removed)
- pull from high beam stalk (one touch/flash)
- open the driver's door.
- the lights turn ON.
Re: numberior´s 2011 Polo 6R GTI DSG
Posted: Wed Oct 25, 2017 5:11 pm
by numberior
Hi Ciclo,
Will put in the code tomorrow
Thanks for making my bi-xenon (and BCM Max upgrade) retrofit a success!
Excellent! a new discovery in the fantastic world of BCM PQ25. (with 7H0 BCMs this would not have happened)
I'm glad to be able to contribute a little, even by accident
I think I want to do the headlight washers next.
Would you be able to help me with this Ciclo? I don't really trust the Kufatec's retrofit kit and rather do the harness(es) myself.
Re: numberior´s 2011 Polo 6R GTI DSG
Posted: Wed Oct 25, 2017 5:34 pm
by numberior
Hi Ciclo,
Is it possible for DRL to dim and not totally turn off on the side that blinks?
https://www.youtube.com/watch?v=G_ZkCvlS2Gw
Re: numberior´s 2011 Polo 6R GTI DSG
Posted: Thu Oct 26, 2017 5:50 am
by ciclo
numberior wrote: ↑Wed Oct 25, 2017 5:11 pm
I think I want to do the headlight washers next.
Would you be able to help me with this Ciclo? I don't really trust the Kufatec's retrofit kit and rather do the harness(es) myself.
The wiring diagram image for this retrofit is somewhere in the forum, several users did it. Search...
The kufatec kit is perfect for your car. (Model Year A, B, C)
Ok, that's a 6C.
For the 6R and electronically speaking it is not possible, there is always some point or legality* in which it fails.
* for those who use the Scandinavian mode (parking/side lights ON witn terminal 15 ON ---> so, light switch in "0" position).
IMHO it's better with the DRLs totally OFF when blinking, ... what is trying to achieve with this function is that others see clearly your blinkers to know what intentions you have when you want to maneuver.
Re: numberior´s 2011 Polo 6R GTI DSG
Posted: Thu Oct 26, 2017 2:52 pm
by numberior
The wiring diagram image for this retrofit is somewhere in the forum, several users did it. Search...
The kufatec kit is perfect for your car. (Model Year A, B, C)
Glad to hear that.
Ok, that's a 6C.
For the 6R and electronically speaking it is not possible, there is always some point or legality* in which it fails.
* for those who use the Scandinavian mode (parking/side lights ON witn terminal 15 ON ---> so, light switch in "0" position).
IMHO it's better with the DRLs totally OFF when blinking, ... what is trying to achieve with this function is that others see clearly your blinkers to know what intentions you have when you want to maneuver.
Thanks for explaining Ciclo.
Re: numberior´s 2011 Polo 6R GTI DSG
Posted: Thu Oct 26, 2017 3:18 pm
by numberior
Hi Ciclo,
Before my bi-xenon retrofit, I had a shop replace engine mounts for me.
They screwed up somehow, damaged my ECU and had to replace it for me.
It was only recently I discovered my cruise control is no longer working.
I have set the engine byte and BCM byte as needed:
Code: Select all
Tuesday,24,October,2017,22:44:13:27502
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64
VCDS Version: 17.8.0.1 (x64)
Data version: 20170721 DS276.2
www.Ross-Tech.com
VIN: WVWZZZ6RZBY312116 License Plate: 15TH SCAN-1ST TEST
Mileage: 100380km-62373mi Repair Order:
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: 6R-VW25 (7E0)
Scan: 01 02 03 04 08 09 15 17 19 25 44 55 56 0B
VIN: WVWZZZ6RZBY312116 Mileage: 100380km-62373miles
01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: Cannot be reached 1100
-------------------------------------------------------------------------------
Address 01: Engine (J623-CAVE) Labels:. 03C-907-309-V1.clb
Part No SW: 03C 906 027 AR HW: 03C 906 027 AR
Component: 1.4l R4 TSI H15 9971
Revision: L2H15--- Serial number: 00000000000000
Coding: 00250012002400000000
Shop #: WSC 12345 123 12345
ASAM Dataset: EV_ECM14TSI01103C906027AR 001014
ROD: EV_ECM14TSI01103C906027AR.rod
VCID: 71E99E02A0C274CE75-8024
No fault code found.
Readiness: 0000 0101
-------------------------------------------------------------------------------
Address 02: Auto Trans
Cannot be reached
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels:. 6R0-907-37x-ESP82.clb
Part No SW: 6R0 907 379 AK HW: 6R0 907 379 AF
Component: ESP8.2i front H05 0001
Revision: --------
Coding: 230248E3416E02B4C42612E382D740811700
Shop #: WSC 00788 648 00255
VCID: 071DD0DAB2465A7ECB-8052
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels: 6R0-907-044.clb
Part No SW: 6R0 907 044 E HW: 6R0 907 044 E
Component: Climatronic H09 0609
Revision: V0000000
VCID: 35616A129C2A18EE69-8060
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 7E0-937-BCM-V1.clb
Part No SW: 7E0 937 090 B HW: 7E0 937 090
Component: BCM PQ25 Max4 H81 0744
Revision: B9081001 Serial number: 0982 321160318
Coding: 3CB02BBF08A1000008380C916C2B0CD05AC0470F60051040200000030000
Shop #: WSC 12345 123 12345
VCID: 2A5B496E45944716F4-807E
Subsystem 1 - Part No SW: 6R0 959 802 AB HW: 6R0 959 802 AB Labels: 6R0-959-802.CLB
Component: J386__TSG_FT 007 1611
Serial number: KU0KU024031100012688
Coding: 18BC30
Subsystem 2 - Part No SW: 6R0 959 801 AD HW: 6R0 959 801 AD Labels: 6R0-959-801.CLB
Component: J387__TSG_BT 007 1611
Serial number: KU0KU016031100015781
Coding: 08BC30
Subsystem 3 - Part No SW: 6R0 959 591 A HW: 7P0 959 591
Component: J245 PS72.015 H05 0006
Serial number: WOO1165901/
Coding: 081001
Subsystem 4 - Part No SW: 5K0 959 542 HW: 5K0 959 542
Component: E221__MFL-TAS H05 0010
Serial number: 0050759
Coding: 830000
Subsystem 5 - Part No SW: 6R0 959 811 G HW: 6R0 959 811 G
Component: J388__TSG_HL 007 1611
Serial number: KU0KU011041100017315
Coding: 08BC32
Subsystem 6 - Part No SW: 6R0 959 812 G HW: 6R0 959 812 G
Component: J389__TSG_HR 007 1611
Serial number: KU0KU011041100013053
Coding: 08BC32
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:| 5K0-959-655.clb
Part No SW: 6R0 959 655 M HW: 6R0 959 655 M
Component: VW10Airbag01E H09 0020
Revision: -------- Serial number: 003GZ000HCNK
Coding: 003145
Shop #: WSC 00788 648 00255
ASAM Dataset: EV_AirbaVW10BPAVW250 A01001
ROD: EV_AirbaVW10BPAVW250_VW25.rod
VCID: 4C972FF6E7A0792626-8018
Crash sensor for side airbag: driver side:
Serial number: 3575HRB40550HJHG9ON%
Crash sensor for side airbag: front passenger side:
Serial number: 3585HRB40590HJHG919A
Crash sensor for side airbag: rear: driver side:
Serial number: 3515RRB405B0I4AG6OGL
Crash sensor for side airbag: rear: passenger side:
Serial number: 3525RRB404R0H4DUHPLR
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5K0-920-xxx-17.clb
Part No SW: 6R0 920 870 HW: 6R0 920 870
Component: KOMBI H21 0320
Serial number: 00000000000000
Coding: 140A00
Shop #: WSC 00788 648 00255
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04086
ROD: EV_Kombi_UDS_VDD_RM09_A04_VW25.rod
VCID: 72EB910EA5C44FD68C-8026
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 7E0-909-901.clb
Part No SW: 7E0 909 901 HW: 7E0 937 090
Component: GW-K-CAN TP20 H81 0744
Revision: B9081001
Coding: 002300
Shop #: WSC 12345 123 12345
VCID: 68DFF3669B18B50622-803C
1 Fault Found:
01304 - Radio
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 10
Mileage: 100245 km
Time Indication: 0
Date: 2012.03.13
Time: 23:57:39
-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels:| 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H21 0320
Serial number:
Coding: 000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03008
ROD: EV_Immo_UDS_VDD_RM09_VW21.rod
VCID: 6ADB896E8D14871634-803E
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 6Q0-423-156.clb
Part No: 6R0 423 156 B
Component: LenkhilfeTRW V277
Coding: 11221
Shop #: WSC 31414
VCID: 2F6D587AEA76223E23-807A
No fault code found.
-------------------------------------------------------------------------------
Address 55: Headlight Range (J431) Labels:. 6R0-907-357.clb
Part No SW: 6R0 907 357 HW: 6R0 907 357
Component: LWR-ECU H02 0070
Revision: -------- Serial number: --------------
Coding: 0114000001000000
Shop #: WSC 12345 123 12345
ASAM Dataset: EV_HeadlRegulVWLWRPt 001004
ROD: EV_HeadlRegulVWLWRPt_VW25.rod
VCID: 77FDA01ACEA62AFEBB-8022
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio
Cannot be reached
End-------------------------(Elapsed Time: 03:02)--------------------------
However, when I try to enter the activation code via
engine-> login, the button is grey out.
I guess I need the security access before I can login?
I would rather sort this out myself than going back to the garage. Downtime is one day they say.
Re: numberior´s 2011 Polo 6R GTI DSG
Posted: Thu Oct 26, 2017 4:36 pm
by iichel
Maybe go your BCM, select advanced measurement values, type cruise in the search box and test all the buttons.
Re: numberior´s 2011 Polo 6R GTI DSG
Posted: Fri Oct 27, 2017 5:05 am
by numberior
iichel wrote: ↑Thu Oct 26, 2017 4:36 pm
Maybe go your BCM, select advanced measurement values, type cruise in the search box and test all the buttons.
Thanks iiche for showing this useful featurel!
Tested all buttons working.
Do I need to re-activate it?
Re: numberior´s 2011 Polo 6R GTI DSG
Posted: Fri Oct 27, 2017 5:12 am
by ciclo
numberior wrote: ↑Thu Oct 26, 2017 3:18 pm
However, when I try to enter the activation code via
engine-> login, the button is grey out.
To code the engine unit (
Coding-07) the engine must be OFF.
According to your last autoscan the cruise control is already activated in both units. (BCM and engine)
Something odd is happening here.
Re: numberior´s 2011 Polo 6R GTI DSG
Posted: Fri Oct 27, 2017 3:11 pm
by numberior
ciclo wrote: ↑Fri Oct 27, 2017 5:12 am
numberior wrote: ↑Thu Oct 26, 2017 3:18 pm
However, when I try to enter the activation code via
engine-> login, the button is grey out.
To code the engine unit (
Coding-07) the engine must be OFF.
According to your last autoscan the cruise control is already activated in both units. (BCM and engine)
Something odd is happening here.
Odd indeed.
It only happened after the ECU change.
I tried to do the cruise control activation.
https://www.youtube.com/watch?v=3RrdtjXe660
But for me
Engine module-> Login-11 is grey out.
Do you know the security access for engine module, and the activation code for cruise control?
Re: numberior´s 2011 Polo 6R GTI DSG
Posted: Fri Oct 27, 2017 3:43 pm
by ciclo
numberior wrote: ↑Fri Oct 27, 2017 3:11 pm
ciclo wrote: ↑Fri Oct 27, 2017 5:12 am
numberior wrote: ↑Thu Oct 26, 2017 3:18 pm
However, when I try to enter the activation code via
engine-> login, the button is grey out.
To code the engine unit (Coding-07) the engine must be OFF.
Odd indeed.
It only happened after the ECU change.
I tried to do the cruise control activation.
https://www.youtube.com/watch?v=3RrdtjXe660
But for me
Engine module-> Login-11 is grey out.
Do you know the security access for engine module, and the activation code for cruise control?
Now,
Byte5 Bit5 (ACC ON, engine OFF)
Disable and enable a couple of times.
Re: numberior´s 2011 Polo 6R GTI DSG
Posted: Fri Oct 27, 2017 4:40 pm
by numberior
Thanks Ciclo,
I'll try it out first thing tomorrow
Re: numberior´s 2011 Polo 6R GTI DSG
Posted: Sat Oct 28, 2017 8:02 am
by numberior
Now,
Byte5 Bit5 (ACC ON, engine OFF)
Image
Disable and enable a couple of times.
Hi Ciclo,
I've tried it.
With ACC on and engine not running,
Clear bit 5->Exit->Do it, Set bit 5->Exit->Do it.
3 cycles I repeated.
Started engine.
On cruise control on stalk, still no cruise control activation indication.
What can I do next?