UPGRADING BCM 6R

Chat about your 6R/6C model Polos here!
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7787
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: UPGRADING BCM 6R

Post by ciclo »

Perfect! Thanks.
VK70
New
Posts: 9
Joined: Mon May 22, 2017 5:43 am
Drives: VW Vento 1.2 TSI Highline
Location: Bangalore

Re: UPGRADING BCM 6R

Post by VK70 »

ciclo wrote:Image

Subsystem 2 - Part No SW: 6R0 959 802 BH HW: 6R0 959 802 BH Labels: 6R0-959-802.CLB
Component: J386__TSG_FT 003 8612
Serial number: KU0KU021021440523980
Coding: 1400B3

Subsystem 3 - Part No SW: 6R0 959 801 BC HW: 6R0 959 801 BC Labels: 6R0-959-801.CLB
Component: J387__TSG_BT 003 8611
Serial number: KU0KU004101300011381
Coding: 0400B3

... and all the functions will work like a charm!... auto folding mirror function too.Image

Image
Thank you very much ciclo and govindsharma.
I will check with my SA in VW if he can source this for me.In case they are not willing to ,can you let me know where you sourced this from.
Thanks again [emoji3]


Sent from my ONEPLUS A5000 using Tapatalk

User avatar
ciclo
Bling Bling Diamond Member
Posts: 7787
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: UPGRADING BCM 6R

Post by ciclo »

These WRMs with those references will be very difficult to find in the second-hand market.

In the ETKA these references have been replaced by new ones.

As the automatic folding function was not available in the optional equipment when buying a 6R on those dates (2013-2014, if you look at the previous image of the WRMs) the WRMs that replace these do not have the auto function in any case .

Therefore, it will be necessary that some magicians (e.g. in Russia there are a few :wink: ) find a way to load these software into WRMs with the appropriate hardware (pins and electrónic parts).

---
A separate comment:

The most difficult thing was to code these WRMs so that all possible functions worked correctly.
In the 6R sold in India with folding mirrors (without auto function) you just have to install and code them with the VCDS. No modification is necessary in the wiring.
The best of luck for the huge number of 6R owners in India who asked me about the WRMs for automatic folding function with remote.Image
govindsharma
Bronze Member
Posts: 109
Joined: Thu Mar 03, 2016 3:17 pm
Drives: polo 1.2 petrol HighLine
Location: india

Re: UPGRADING BCM 6R

Post by govindsharma »

Dear Sir Good Evening
As i installed auto fold side mirror in my polo rain closing with lock is not working.I thing i have to change coding of rain sensor can you please tell me its right coding.At present rain closing is working in door unlock as i lock the door it is not working.Second please suggest me radio which is all the function like navigation phone calls, magnetic compass Bluetooth etc and it has full integration with MFD.

Thank you.
User avatar
iichel
Bling Bling Diamond Member
Posts: 6361
Joined: Fri Nov 14, 2014 2:14 pm
Drives: Polo 6R 2.0 TDI, Passat B8 2.0 TSI
Location: http://mypassat.nl/

Re: UPGRADING BCM 6R

Post by iichel »

RNS310, RNS315, RNS510, Discover Media PQ (needs component protection deactivation).
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7787
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: UPGRADING BCM 6R

Post by ciclo »

govindsharma wrote: Sun Jan 28, 2018 11:18 am Dear Sir Good Evening
As i installed auto fold side mirror in my polo rain closing with lock is not working.I thing i have to change coding of rain sensor (NO). can you please tell me its right coding. At present rain closing is working in door unlock as i lock the door it is not working.
Thank you.
Your RLS coding is right.

Same as mine.

Is the Rain Closing function in the 6R possible with the car locked? YES. :lol:
govindsharma
Bronze Member
Posts: 109
Joined: Thu Mar 03, 2016 3:17 pm
Drives: polo 1.2 petrol HighLine
Location: india

Re: UPGRADING BCM 6R

Post by govindsharma »

ciclo wrote: Sun Jan 28, 2018 1:32 pm
govindsharma wrote: Sun Jan 28, 2018 11:18 am Dear Sir Good Evening
As i installed auto fold side mirror in my polo rain closing with lock is not working.I thing i have to change coding of rain sensor (NO). can you please tell me its right coding. At present rain closing is working in door unlock as i lock the door it is not working.
Thank you.
Your RLS coding is right.

Same as mine.

Is the Rain Closing function in the 6R possible with the car locked? YES. :lol:
Sir Than how can it work tell me please.
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7787
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: UPGRADING BCM 6R

Post by ciclo »

govindsharma wrote: Sun Jan 28, 2018 1:39 pm Sir Than how can it work tell me please.
I sent you an email. Do the tests. :wink:
govindsharma
Bronze Member
Posts: 109
Joined: Thu Mar 03, 2016 3:17 pm
Drives: polo 1.2 petrol HighLine
Location: india

Re: UPGRADING BCM 6R

Post by govindsharma »

Dear Good Afternoon
Can anyone tell me how to install diversity antenna in VW polo 6R. What parts are required for this antenna and connection diagram of it.
Thanks in advance if anyone help me in this regard.


Thank you.
User avatar
ciclo
Bling Bling Diamond Member
Posts: 7787
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R'13/G7.5'19
Location: Earth ♥, sPAIN, Magiclands (Mordor).
Contact:

Re: UPGRADING BCM 6R

Post by ciclo »

raghav.rithvik
New
Posts: 10
Joined: Thu Jan 04, 2018 2:56 am
Drives: Polo 6r 1.2 TSI DSG
Location: India

Re: UPGRADING BCM 6R

Post by raghav.rithvik »

Apologies for hijacking your post.
Re: Ciclo
I have the following setup

Polo 6r 1.2 GT TSI (India)

Code: Select all

 Tuesday,20,February,2018,16:33:01:00001

VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64(Parallels)

VCDS Version 17.8.0.1

Data version: 20170721 DS276.2

www.Ross-Tech.com





VIN: MEXB16605GT0XXXXX   License Plate: DOORMODULECHANGE

Mileage: 28370km-17628mi   Repair Order: 







--------------------------------------------------------------------------------

--------------------------------------------------------------------------------





Chassis Type: 60-VW25 (6RU)

Scan: 01 02 03 08 09 10 15 17 19 25 44 56



VIN: MEXB16605GT0XXXXX   Mileage: 28370km-17628miles



01-Engine -- Status: OK 0000

02-Auto Trans -- Status: OK 0000

03-ABS Brakes -- Status: Malfunction 0010

04-Steering Angle -- Status: OK 0000

08-Auto HVAC -- Status: OK 0000

09-Cent. Elect. -- Status: OK 0000

10-Park/Steer Assist -- Status: OK 0000

15-Airbags -- Status: OK 0000

17-Instruments -- Status: OK 0000

19-CAN Gateway -- Status: OK 0000

25-Immobilizer -- Status: OK 0000

44-Steering Assist -- Status: OK 0000

56-Radio -- Status: OK 0000

 

-------------------------------------------------------------------------------

Address 01: Engine (J623-CBZB)       Labels:. 03F-906-070-CBZ.clb

   Part No SW: 03F 906 070 KC    HW: 03F 907 309 AJ

   Component: SIMOS10.22AH10 6270  

   Revision: --H10---    Serial number:               

   Coding: 00250056232400080000

   Shop #: WSC 01234 785 00200

   ASAM Dataset: EV_ECM12TFS02103F906070KC 004006

   ROD: EV_ECM12TFS02103F906070FP.rod

   VCID: 6DD0F128BC91FF2E51-8039



No fault code found.

Readiness: 0010 0101



-------------------------------------------------------------------------------

Address 02: Auto Trans        Labels: 0AM-927-769.clb

   Part No SW: 0AM 300 065 N    HW: 0AM 927 769 D

   Component: GSG DSG AG7     431 6501  

   Revision: 00043014    Serial number: CU501510177213

   Coding: 0000020

   Shop #: WSC 01324 785 00200

   VCID: 3A7A0A74755F989684-806F



No fault code found.



-------------------------------------------------------------------------------

Address 03: ABS Brakes (J104)       Labels:. 6R0-907-37x-ESP90.clb

   Part No SW: 6R0 907 379 BN    HW: 6R0 907 379 AS

   Component: ESP9.0i front H03 0001  

   Serial number: --------------

   Coding: 62DD2463422A03C3461A246A4251C0800909

   Shop #: WSC 01234 785 00200

   ASAM Dataset: EV_Brake1ESP90iBOSCH 003031

   ROD: EV_Brake1ESP90iBOSCH_003_VW21.rod

   VCID: 0B149FB0A245511EEF-805F



1 Fault Found:

0631 - Tire Pressure Warning 

          C102D 00 [137] -  - 

          MIL ON - Confirmed - Tested Since Memory Clear

             Freeze Frame:

                    Fault Status: 00000001

                    Fault Priority: 2

                    Fault Frequency: 11

                    Reset counter: 0

                    Mileage: 28323 km

                    Date: 2018.02.19

                    Time: 08:32:49





-------------------------------------------------------------------------------

Address 08: Auto HVAC (J255)       Labels: 6R0-907-044.clb

   Part No SW: 6R0 907 044 Q    HW: 6R0 907 044 Q

   Component: Climatronic   H12 0615  

   Revision: V0000000    

   VCID: 41887D98D889CB4EC5-8015



No fault code found.



-------------------------------------------------------------------------------

Address 09: Cent. Elect. (J519)       Labels:. 6R0-937-08x-09.clb

   Part No SW: 6RU 937 087 M    HW: 6RU 937 087 

   Component: BCM IM H+4    H40 0432  

   Revision: BZ040001    Serial number: 0300 027160122

   Coding: 3AB82BFF48A30000013800007EAB0690F0C041FF608C0000200000000000

   Shop #: WSC 124697 483 00190

   VCID: 6CD6FC2C8F8BF62646-8039



   Subsystem 1 - Part No: 5K7 955 559 B  Labels: 5K7-955-559.CLB

   Component: RLS 081215 03  37  0059 

   Coding: 0368DD



   Subsystem 2 - Part No SW: 6R0 959 802 BH    HW: 6R0 959 802 BH  Labels: 6R0-959-802.CLB

   Component: J386__TSG_FT  003 8612 

   Serial number: KU0KU028041441181703

   Coding: 1400B1



   Subsystem 3 - Part No SW: 6R0 959 801 BC    HW: 6R0 959 801 BC  Labels: 6R0-959-801.CLB

   Component: J387__TSG_BT  003 8611 

   Serial number: KU0KU013011440132823

   Coding: 0400B3



   Subsystem 4 - Part No SW: 31G 959 442     HW: 31G 959 442 

   Component: E221__MFL-TAT  H06 0023 

   Serial number: 2991512270400366CX3J

   Coding: 250000



   Subsystem 5 - Part No SW: 6R0 959 811 S    HW: 6R0 959 811 S

   Component: J388__TSG_HL  019 1552 

   Serial number: 13202728151126171114

   Coding: 000000



   Subsystem 6 - Part No SW: 6R0 959 812 S    HW: 6R0 959 812 S

   Component: J389__TSG_HR  019 1552 

   Serial number: 13202729151127015206

   Coding: 000000



No fault code found.



-------------------------------------------------------------------------------

Address 10: Park/Steer Assist (J446)       Labels:* None

   Part No SW: 18D 919 475 A    HW: 56D 919 475 

   Component: PARKHILFE 8K  H02 0003  

   Revision: --------    Serial number: 20841526700549

   Coding: 308001

   Shop #: WSC 12345 123 12345

   ASAM Dataset: EV_EPHVA18VW3218CS0 001002

   ROD: EV_VW75XParkAssis8K_VW31.rod

   VCID: 31682D5860295BCE35-8064



No fault code found.

-------------------------------------------------------------------------------

Address 15: Airbags (J234)       Labels:| 5K0-959-655.clb

   Part No SW: 6R0 959 655 J    HW: 6R0 959 655 J

   Component: VW10AirbagU06 H10 0020  

   Revision: --------    Serial number: 003GW012F7ND

   Coding: 003036

   Shop #: WSC 01234 785 00200

   ASAM Dataset: EV_AirbaVW10BPAVW250 A01001

   ROD: EV_AirbaVW10BPAVW250_VW25.rod

   VCID: 499865B8E8B9030E1D-801C



No fault code found.



-------------------------------------------------------------------------------

Address 17: Instruments (J285)       Labels:| 5K0-920-xxx-17.clb

   Part No SW: 6RD 920 870 A    HW: 6RD 920 870 A

   Component: KOMBI         H05 0805  

   Serial number: 00000000000000

   Coding: 140A01

   Shop #: WSC 12345 123 12345

   ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04727

   ROD: EV_Kombi_UDS_VDD_RM09_A04_VW25.rod

   VCID: 479C6380FEADF57E0B-8012


No fault code found.



-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels: None

   Part No SW: 6RU 909 901     HW: 6RU 937 087 

   Component: GW-K-CAN TP20 H40 0432  

   Revision: BZ040001    

   Coding: 002300

   Shop #: WSC 124697 483 00190

   VCID: 1938F5F81099B38E6D-804C


No fault code found.



-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels:| 5K0-920-xxx-25.clb

   Part No SW: 5K0 953 234     HW: 5K0 953 234 

   Component: IMMO          H05 0805  

   Serial number: 00000000000000

   Coding: 000000

   Shop #: WSC 00000 000 00000

   ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03710

   ROD: EV_Immo_UDS_VDD_RM09_VW21.rod

   VCID: 6ADAFA348D7FE81634-803E



No fault code found.



-------------------------------------------------------------------------------

Address 44: Steering Assist (J500)       Labels:| 1Sx-909-144-44.clb

   Part No SW: 1S2 909 144 P    HW: 1S2 909 144 P

   Component: EPS_ECU       H61 1702  

   Coding: 0001000000000000

   Shop #: WSC 00000 000 00000

   ASAM Dataset: EV_SteerAssisNSK 014008

   ROD: EV_SteerAssisNSK_014_VW12.rod

   VCID: 41887D98D089CB4EC5-8014



No fault code found.



-------------------------------------------------------------------------------
Address 56: Radio (J503)       Labels:. 5M0-035-1xx-56.clb

   Part No SW: 6RD 035 187 A    HW: 6RD 035 187 A

   Component: Radio         526 Crng  

   Revision: --------    Serial number: VWZZZ4Q5129492

   Coding: 08000440010005

   Shop #: WSC 00070 123 12345

   VCID: 45806988CCA1E76EF9-8010



No fault code found.
 
I managed to buy the door modules (6r0959802BH & 6r0959801BC) I've used the long codes 1400B1 & 0400B3 respectively.
The issue is as follows,
-left-right & up-down mirror control for both sides have swapped (up does right, down does left & vice versa)
-Only the left mirror(passenger) auto folds (however both fold when I turn the switch on the door)

I also managed to enable passive TPMS on the car by changing the last byte of the ABS module code & IC enabling. Works perfectly. I purchased the reset switch 1K0927121C. Could you help me with the pin config for the ESP module to connect the switch?

P.S. Would you like me to open a new thread completely?


Update : managed to get the mirrors working as intended using 1400B3 for RHD mirror.
Last edited by raghav.rithvik on Tue Feb 20, 2018 2:31 pm, edited 2 times in total.
User avatar
iichel
Bling Bling Diamond Member
Posts: 6361
Joined: Fri Nov 14, 2014 2:14 pm
Drives: Polo 6R 2.0 TDI, Passat B8 2.0 TSI
Location: http://mypassat.nl/

Re: UPGRADING BCM 6R

Post by iichel »

excuse my potential rude remark, but there are other users apart from ciclo in this forum that are capable of helping you out.

pin 4 of the 38-pin connector to the ABS unit goes to pin 4 of the 6-pin connector of the push button.
pin 5 of the 6-pin connector of the push button goes to a +15 (ignition switched 12V, pin 35 blue/black wire of the ABS connector)
pin 6 of the 6-pin connector of the push button goes to a ground point, i.e. connect it to the dash cross member
pin 3 of the 6-pin connector of the push button goes to the button illumination signal (i.e. grey/blue wire in the T28 pin connector of the door wiring loom)
raghav.rithvik
New
Posts: 10
Joined: Thu Jan 04, 2018 2:56 am
Drives: Polo 6r 1.2 TSI DSG
Location: India

Re: UPGRADING BCM 6R

Post by raghav.rithvik »

iichel wrote: Tue Feb 20, 2018 1:17 pm excuse my potential rude remark, but there are other users apart from ciclo in this forum that are capable of helping you out.

pin 4 of the 38-pin connector to the ABS unit goes to pin 4 of the 6-pin connector of the push button.
pin 5 of the 6-pin connector of the push button goes to a +15 (ignition switched 12V, pin 35 blue/black wire of the ABS connector)
pin 6 of the 6-pin connector of the push button goes to a ground point, i.e. connect it to the dash cross member
pin 3 of the 6-pin connector of the push button goes to the button illumination signal (i.e. grey/blue wire in the T28 pin connector of the door wiring loom)

Apologies iichel, I meant no disrespect by directing my question. Big fan of your posts.

The pin 4 on my T38 connector is already occupied by a grey wire. However, ESP switch is connected to 15 or 16 (not entirely sure of this number) as I checked continuity to ESP switch pin 4. Should I add TPMS to T38/4?
govindsharma
Bronze Member
Posts: 109
Joined: Thu Mar 03, 2016 3:17 pm
Drives: polo 1.2 petrol HighLine
Location: india

Re: UPGRADING BCM 6R

Post by govindsharma »

raghav.rithvik wrote: Tue Feb 20, 2018 1:03 pm Apologies for hijacking your post.
Re: Ciclo
I have the following setup

Polo 6r 1.2 GT TSI (India)

Code: Select all

 Tuesday,20,February,2018,16:33:01:00001

VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64(Parallels)

VCDS Version 17.8.0.1

Data version: 20170721 DS276.2

www.Ross-Tech.com





VIN: MEXB16605GT0XXXXX   License Plate: DOORMODULECHANGE

Mileage: 28370km-17628mi   Repair Order: 







--------------------------------------------------------------------------------

--------------------------------------------------------------------------------





Chassis Type: 60-VW25 (6RU)

Scan: 01 02 03 08 09 10 15 17 19 25 44 56



VIN: MEXB16605GT0XXXXX   Mileage: 28370km-17628miles



01-Engine -- Status: OK 0000

02-Auto Trans -- Status: OK 0000

03-ABS Brakes -- Status: Malfunction 0010

04-Steering Angle -- Status: OK 0000

08-Auto HVAC -- Status: OK 0000

09-Cent. Elect. -- Status: OK 0000

10-Park/Steer Assist -- Status: OK 0000

15-Airbags -- Status: OK 0000

17-Instruments -- Status: OK 0000

19-CAN Gateway -- Status: OK 0000

25-Immobilizer -- Status: OK 0000

44-Steering Assist -- Status: OK 0000

56-Radio -- Status: OK 0000

 

-------------------------------------------------------------------------------

Address 01: Engine (J623-CBZB)       Labels:. 03F-906-070-CBZ.clb

   Part No SW: 03F 906 070 KC    HW: 03F 907 309 AJ

   Component: SIMOS10.22AH10 6270  

   Revision: --H10---    Serial number:               

   Coding: 00250056232400080000

   Shop #: WSC 01234 785 00200

   ASAM Dataset: EV_ECM12TFS02103F906070KC 004006

   ROD: EV_ECM12TFS02103F906070FP.rod

   VCID: 6DD0F128BC91FF2E51-8039



No fault code found.

Readiness: 0010 0101



-------------------------------------------------------------------------------

Address 02: Auto Trans        Labels: 0AM-927-769.clb

   Part No SW: 0AM 300 065 N    HW: 0AM 927 769 D

   Component: GSG DSG AG7     431 6501  

   Revision: 00043014    Serial number: CU501510177213

   Coding: 0000020

   Shop #: WSC 01324 785 00200

   VCID: 3A7A0A74755F989684-806F



No fault code found.



-------------------------------------------------------------------------------

Address 03: ABS Brakes (J104)       Labels:. 6R0-907-37x-ESP90.clb

   Part No SW: 6R0 907 379 BN    HW: 6R0 907 379 AS

   Component: ESP9.0i front H03 0001  

   Serial number: --------------

   Coding: 62DD2463422A03C3461A246A4251C0800909

   Shop #: WSC 01234 785 00200

   ASAM Dataset: EV_Brake1ESP90iBOSCH 003031

   ROD: EV_Brake1ESP90iBOSCH_003_VW21.rod

   VCID: 0B149FB0A245511EEF-805F



1 Fault Found:

0631 - Tire Pressure Warning 

          C102D 00 [137] -  - 

          MIL ON - Confirmed - Tested Since Memory Clear

             Freeze Frame:

                    Fault Status: 00000001

                    Fault Priority: 2

                    Fault Frequency: 11

                    Reset counter: 0

                    Mileage: 28323 km

                    Date: 2018.02.19

                    Time: 08:32:49





-------------------------------------------------------------------------------

Address 08: Auto HVAC (J255)       Labels: 6R0-907-044.clb

   Part No SW: 6R0 907 044 Q    HW: 6R0 907 044 Q

   Component: Climatronic   H12 0615  

   Revision: V0000000    

   VCID: 41887D98D889CB4EC5-8015



No fault code found.



-------------------------------------------------------------------------------

Address 09: Cent. Elect. (J519)       Labels:. 6R0-937-08x-09.clb

   Part No SW: 6RU 937 087 M    HW: 6RU 937 087 

   Component: BCM IM H+4    H40 0432  

   Revision: BZ040001    Serial number: 0300 027160122

   Coding: 3AB82BFF48A30000013800007EAB0690F0C041FF608C0000200000000000

   Shop #: WSC 124697 483 00190

   VCID: 6CD6FC2C8F8BF62646-8039



   Subsystem 1 - Part No: 5K7 955 559 B  Labels: 5K7-955-559.CLB

   Component: RLS 081215 03  37  0059 

   Coding: 0368DD



   Subsystem 2 - Part No SW: 6R0 959 802 BH    HW: 6R0 959 802 BH  Labels: 6R0-959-802.CLB

   Component: J386__TSG_FT  003 8612 

   Serial number: KU0KU028041441181703

   Coding: 1400B1



   Subsystem 3 - Part No SW: 6R0 959 801 BC    HW: 6R0 959 801 BC  Labels: 6R0-959-801.CLB

   Component: J387__TSG_BT  003 8611 

   Serial number: KU0KU013011440132823

   Coding: 0400B3



   Subsystem 4 - Part No SW: 31G 959 442     HW: 31G 959 442 

   Component: E221__MFL-TAT  H06 0023 

   Serial number: 2991512270400366CX3J

   Coding: 250000



   Subsystem 5 - Part No SW: 6R0 959 811 S    HW: 6R0 959 811 S

   Component: J388__TSG_HL  019 1552 

   Serial number: 13202728151126171114

   Coding: 000000



   Subsystem 6 - Part No SW: 6R0 959 812 S    HW: 6R0 959 812 S

   Component: J389__TSG_HR  019 1552 

   Serial number: 13202729151127015206

   Coding: 000000



No fault code found.



-------------------------------------------------------------------------------

Address 10: Park/Steer Assist (J446)       Labels:* None

   Part No SW: 18D 919 475 A    HW: 56D 919 475 

   Component: PARKHILFE 8K  H02 0003  

   Revision: --------    Serial number: 20841526700549

   Coding: 308001

   Shop #: WSC 12345 123 12345

   ASAM Dataset: EV_EPHVA18VW3218CS0 001002

   ROD: EV_VW75XParkAssis8K_VW31.rod

   VCID: 31682D5860295BCE35-8064



No fault code found.

-------------------------------------------------------------------------------

Address 15: Airbags (J234)       Labels:| 5K0-959-655.clb

   Part No SW: 6R0 959 655 J    HW: 6R0 959 655 J

   Component: VW10AirbagU06 H10 0020  

   Revision: --------    Serial number: 003GW012F7ND

   Coding: 003036

   Shop #: WSC 01234 785 00200

   ASAM Dataset: EV_AirbaVW10BPAVW250 A01001

   ROD: EV_AirbaVW10BPAVW250_VW25.rod

   VCID: 499865B8E8B9030E1D-801C



No fault code found.



-------------------------------------------------------------------------------

Address 17: Instruments (J285)       Labels:| 5K0-920-xxx-17.clb

   Part No SW: 6RD 920 870 A    HW: 6RD 920 870 A

   Component: KOMBI         H05 0805  

   Serial number: 00000000000000

   Coding: 140A01

   Shop #: WSC 12345 123 12345

   ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04727

   ROD: EV_Kombi_UDS_VDD_RM09_A04_VW25.rod

   VCID: 479C6380FEADF57E0B-8012


No fault code found.



-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels: None

   Part No SW: 6RU 909 901     HW: 6RU 937 087 

   Component: GW-K-CAN TP20 H40 0432  

   Revision: BZ040001    

   Coding: 002300

   Shop #: WSC 124697 483 00190

   VCID: 1938F5F81099B38E6D-804C


No fault code found.



-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels:| 5K0-920-xxx-25.clb

   Part No SW: 5K0 953 234     HW: 5K0 953 234 

   Component: IMMO          H05 0805  

   Serial number: 00000000000000

   Coding: 000000

   Shop #: WSC 00000 000 00000

   ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03710

   ROD: EV_Immo_UDS_VDD_RM09_VW21.rod

   VCID: 6ADAFA348D7FE81634-803E



No fault code found.



-------------------------------------------------------------------------------

Address 44: Steering Assist (J500)       Labels:| 1Sx-909-144-44.clb

   Part No SW: 1S2 909 144 P    HW: 1S2 909 144 P

   Component: EPS_ECU       H61 1702  

   Coding: 0001000000000000

   Shop #: WSC 00000 000 00000

   ASAM Dataset: EV_SteerAssisNSK 014008

   ROD: EV_SteerAssisNSK_014_VW12.rod

   VCID: 41887D98D089CB4EC5-8014



No fault code found.



-------------------------------------------------------------------------------
Address 56: Radio (J503)       Labels:. 5M0-035-1xx-56.clb

   Part No SW: 6RD 035 187 A    HW: 6RD 035 187 A

   Component: Radio         526 Crng  

   Revision: --------    Serial number: VWZZZ4Q5129492

   Coding: 08000440010005

   Shop #: WSC 00070 123 12345

   VCID: 45806988CCA1E76EF9-8010



No fault code found.
 
I managed to buy the door modules (6r0959802BH & 6r0959801BC) I've used the long codes 1400B1 & 0400B3 respectively.
The issue is as follows,
-left-right & up-down mirror control for both sides have swapped (up does right, down does left & vice versa)
-Only the left mirror(passenger) auto folds (however both fold when I turn the switch on the door)

I also managed to enable passive TPMS on the car by changing the last byte of the ABS module code & IC enabling. Works perfectly. I purchased the reset switch 1K0927121C. Could you help me with the pin config for the ESP module to connect the switch?

P.S. Would you like me to open a new thread completely?


Update : managed to get the mirrors working as intended using 1400B3 for RHD mirror.
Can you please elaborate the operation of WRMS in your polo by this coding Ciclo sir can help you regarding this or may be i will tell you the correct coding of that.
User avatar
iichel
Bling Bling Diamond Member
Posts: 6361
Joined: Fri Nov 14, 2014 2:14 pm
Drives: Polo 6R 2.0 TDI, Passat B8 2.0 TSI
Location: http://mypassat.nl/

Re: UPGRADING BCM 6R

Post by iichel »

i was probably looking at esp8.2i but you need esp9.0i.

pin 12 of the 38-pin connector to the ABS unit goes to pin 4 of the 6-pin connector of the push button.
pin 5 of the 6-pin connector of the push button goes to a +15 (ignition switched 12V, pin 28 blue/black wire of the ABS connector)
pin 6 of the 6-pin connector of the push button goes to a ground point, i.e. connect it to the dash cross member
pin 3 of the 6-pin connector of the push button goes to the button illumination signal (i.e. grey/blue wire in the T28 pin connector of the door wiring loom)
Post Reply