IMPORTANT ALL MEMBERS

All members need to read the following page The new General Data Protection Regulations 2018 (GDPR)

Failure to read and accept the new privacy policy may result in your account being deleted, so please take a quick read

Cheers

The UK-Polos.NET Admin Team

Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Chat about your 6R/6C model Polos here!
User avatar
iichel
Bling Bling Diamond Member
Posts: 2844
Joined: Fri Nov 14, 2014 2:14 pm
Drives: Polo 6R 1.2 TDI
Location: kessiichel is everywhere :)

Re: Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Post by iichel » Thu May 17, 2018 2:35 pm

So with
3A904BBF48A10000013807006CCB96900080604F60CD31E1210000030020
The fogs are not working and only one static cornering light works (left)

With this coding:
3A904BBF48E10200013807916CCB96905A88676F608D30C1200000030000
Front fogs are working? And both static cornering lights?

vento2013
New
Posts: 49
Joined: Fri Mar 02, 2018 8:44 am
Drives: 6R Polo(Vento)1.6TDi, Skoda Fabia 1.2MPi
Location: India

Re: Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Post by vento2013 » Thu May 17, 2018 3:19 pm

Yes.

User avatar
ciclo
Bling Bling Diamond Member
Posts: 4363
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R '13
Location: Earth ♥, Spain ☼
Contact:

Re: Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Post by ciclo » Thu May 17, 2018 5:32 pm

vento2013 wrote:
Thu May 17, 2018 12:44 pm
ciclo wrote:
Wed May 16, 2018 4:40 pm
BCM
New coding
3A904BBF48A10000013807006CCB96900080604F60CD31E1210000030020
After this coding observation as below
Pass light(using left stalk) = working fine only High beam
Switch position to parking = Parking is ON
Fog lights = working (when fog is on parking off)
SCL = Only Left cornering is working. Right side not working
Auto scan did No errors in installation list but in address line 04(Attached new scan report)
1 Fault Found:
1140738 - Steering angle sensor
B1168 54 [009] - Missing Calibration / Basic Setting
it was not there earlier

1

The fault of the steering angle G85 is not visible in the previous autoscan with/due to VCDS 12.12, even the address 04 (G85) does not appear in the reading (check it), but the fault is present since then.
With the VCDS 17.1 the fault and the reading of this address 04 are present.

SCLs depend of steering angle G85 (address 04), so...

Are you absolutely sure that the locking mechanism of the T41 connector is firmly tightened?
It is a very common failure in these processes. The tab must go to the end. PUSH IT firmly.


2

Your BCM coding copied from Shardul's Vento is totally wrong for your Vento and LED headlights. Don't use it again.


3

Use only my new BCM coding (perfect coding for your LED headlights), it is the starting point to make your "LED headlights" work properly when you install the right parts, BCM, ...

Wait for me to correct the new BCM coding for your "current electrical installation".

Will be corrected again depending of the results.


Note: What is clear in the autoscan is that all wiring that I sent you work perfectly, another very different thing is the compatibility of the parts, lights, wires, G85, etc ... that you decide to install in your Vento. :lol:

User avatar
ciclo
Bling Bling Diamond Member
Posts: 4363
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R '13
Location: Earth ♥, Spain ☼
Contact:

Re: Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Post by ciclo » Thu May 17, 2018 5:39 pm

3A904BBF48A10000013807006CCB96900080606F60CD39E1210000030020

Tell us the result. Light by light, please.

vento2013
New
Posts: 49
Joined: Fri Mar 02, 2018 8:44 am
Drives: 6R Polo(Vento)1.6TDi, Skoda Fabia 1.2MPi
Location: India

Re: Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Post by vento2013 » Thu May 17, 2018 7:26 pm

ciclo wrote:
Thu May 17, 2018 5:39 pm
3A904BBF48A10000013807006CCB96900080606F60CD39E1210000030020

DRL = OK
Pass Light = OK (Only High beam)
Parking light = OK (When Headlight is on parking is OFF) Need Specific BCM.
Low Beam = OK
High Beam = OK
Fog Lights = OK (Parking goes OFF)
Static Cornering = Not working
CH/LH = OK

Code: Select all

Thursday,17,May,2018,23:07:53:39744
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x86
VCDS Version: 17.1.3.0
Data version: 20170220 DS267.3
www.Ross-Tech.com


VIN: WVWJ13601ET024078   License Plate: KA47M3663
Mileage: 62340km-38736mi   Repair Order: Ciclo code2



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 60 (7E0)
Scan: 01 03 04 08 09 10 15 17 19 25 44 56 0B

VIN: WVWJ13601ET024078   Mileage: 62340km-38736miles

01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
56-Radio -- Status: OK 0000
 
-------------------------------------------------------------------------------
Address 01: Engine (J623-CLNA)       Labels: 03L-906-023-CAY.clb
   Part No SW: 03L 906 023 NT    HW: 03L 907 425 B
   Component: 1,6l R4 CR td H33 9971  
   Revision: --H33---    Serial number: 00000000000000
   Coding: 00110016032500080000
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_ECM16TDI02103L906023NT 003012
   ROD: EV_ECM16TDI02103L906023MJ.rod
   VCID: 05064A5684BA6669DA-8050

No fault code found.
Readiness: 0000 1000

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels: Redir Fail!
   Part No SW: 6R0 907 379 BF    HW: 6R0 907 379 AQ
   Component: ABS9.0 front  H01 0001  
   Serial number: --------------
   Coding: 60DD2F63212504C40614F470845920020000
   Shop #: WSC 57830 002 1048576
   ASAM Dataset: EV_Brake1ABS90BOSCH 003017
   ROD: EV_Brake1ABS90BOSCH_VW25.rod
   VCID: 0302544E8A8E5859F4-8056

No fault code found.

-------------------------------------------------------------------------------
Address 04: Steering Angle (G085)       Labels: 6R0-959-654.clb
   Part No SW: 6R0 959 654     HW: 6R0 959 654 
   Component: LENKW.SENSOR  H07 0070  
   Serial number: 23101713470492
   Coding: 01
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_LWSKLOVW25X 005001
   ROD: EV_LWSKLOVW25X.rod
   VCID: 7EF425BAE16C35B19B-802A

1 Fault Found:
1140738 - Steering angle sensor 
          B1168 54 [009] - Missing Calibration / Basic Setting
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 7
                    Mileage: 62345 km
                    Date: 2016.01.30
                    Time: 22:59:31

                    Voltage terminal 15: 12.00 V
                    Voltage terminal 30: 12.30 V
                    Terminal 15 status: On


-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels: 6R0-907-044.clb
   Part No SW: 6R0 907 044 L    HW: 6R0 907 044 L
   Component: Climatronic   H12 0612  
   Revision: V0000000    
   VCID: 3C70EFB2BFF0E7A1F5-8068

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels: 7E0-937-BCM-V1.clb
   Part No SW: 7E0 937 090 C    HW: 7E0 937 090 C
   Component: BCM PQ25 Max4 H82 0752  
   Revision: B9082001    Serial number: 4000 320170423
   Coding: 3A904BBF48A10000013807006CCB96900080606F60CD39E1210000030020
   Shop #: WSC 00788 648 00255
   VCID: 2B52DCEE4A9E70196C-807E

   Subsystem 1 - Part No: 5K7 955 559 C  Labels: 5K7-955-559.CLB
   Component: RLS 230118 04  47  0106 
   Coding: 0728DD

   Subsystem 2 - Part No SW: 6R0 959 802 AL    HW: 6R0 959 802 AL  Labels: 6R0-959-802.CLB
   Component: -------------  006 5520 
   Serial number: 13202576130625091059
   Coding: 010000

   Subsystem 3 - Part No SW: 6R0 959 801 AH    HW: 6R0 959 801 AH  Labels: 6R0-959-801.CLB
   Component: -------------  006 5520 
   Serial number: 13102579130618031221
   Coding: 010000

   Subsystem 4 - Part No SW: 6C0 959 442     HW: 6C0 959 442 
   Component: E221__MFL-TAT  H04 0019 
   Serial number: 2671409414901055AB1B
   Coding: 240000

   Subsystem 5 - Part No SW: 6R0 959 811 L    HW: 6R0 959 811 L
   Component: -------------  006 5520 
   Serial number: 13102580130620031450
   Coding: 020000

   Subsystem 6 - Part No SW: 6R0 959 812 L    HW: 6R0 959 812 L
   Component: -------------  006 5520 
   Serial number: 13102581130620063454
   Coding: 020000

No fault code found.

-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446)       Labels: 6R0-919-475.clb
   Part No SW: 6R0 919 475 C    HW: 7E0 919 475 
   Component: PARKHILFE 4K  H11 0013  
   Revision: --------    Serial number: 47361317300143
   Coding: 108002
   Shop #: WSC 00793 648 00255
   ASAM Dataset: EV_VW250ParkiAssis2 S01008
   ROD: EV_VW250ParkiAssis2.rod
   VCID: 3E74E5BAA1ECF5B1DB-806A

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels: 5K0-959-655.clb
   Part No SW: 6R0 959 655 J    HW: 6R0 959 655 J
   Component: VW10AirbagU06 H10 0020  
   Revision: --------    Serial number: 003GW00M0RR+
   Coding: 003036
   Shop #: WSC 01383 785 00200
   ASAM Dataset: EV_AirbaVW10BPAVW250 A01001
   ROD: EV_AirbaVW10BPAVW250_VW25.rod
   VCID: 499E8666E82242097E-801C

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels: 5K0-920-xxx-17.clb
   Part No SW: 6RF 920 862     HW: 6RF 920 862 
   Component: KOMBI         H01 0214  
   Serial number: 00000000000000
   Coding: 140A000000
   Shop #: WSC 13202 938 00000
   ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A05729
   ROD: EV_Kombi_UDS_VDD_RM09_004_VW25.rod
   VCID: 091E4666A8A20209BE-805C

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels: None
   Part No SW: 7E0 909 901     HW: 7E0 937 090 C
   Component: GW-K-CAN TP20 H82 0752  
   Revision: B9082001    
   Coding: 002300
   Shop #: WSC 00788 648 00255
   VCID: 68D863E29BE89B0141-803C

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels: 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5K0 953 234 
   Component: IMMO          H01 0214  
   Serial number:               
   Coding: 000000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03710
   ROD: EV_Immo_UDS_VDD_RM09_VW21.rod
   VCID: 6ADC19EA8DE4A91157-803E

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist (J792)       Labels: 6Rx-909-144-V1.clb
   Part No SW: 6RF 909 144 K    HW: 6RF 909 144 J
   Component: EPS_ECU       H44 0401  
   Coding: 0000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_SteerAssisUDSNSK 005005
   ROD: EV_SteerAssisUDSNSK_SK26.rod
   VCID: 54A0A7123F600FE11D-8000

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (J503)       Labels: None
   Part No SW: 6RD 035 187 B    HW: 6RD 035 187 B
   Component: Radio         534 5314  
   Revision: --------    Serial number: VWZZZ4H6267388
   Coding: 16000440040005
   Shop #: WSC 127395 840 08317
   VCID: 46848D5AF13CAD7193-8012

No fault code found.

End-------------------------(Elapsed Time: 02:44)--------------------------
I have made small change in code
3A904BBF48A10000013807006CCB96900080676F60CD39E1210000030020

DRL = OK
Pass Light = OK (Only High beam)
Parking light = OK (When Headlight is on parking is OFF) Need Specific BCM.
Low Beam = OK
High Beam = OK
Fog Lights = OK (Parking goes OFF)
Static Cornering = OK Working perfectly
CH/LH = OK

Code: Select all

Thursday,17,May,2018,23:30:50:39744
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x86
VCDS Version: 17.1.3.0
Data version: 20170220 DS267.3
www.Ross-Tech.com


VIN: WVWJ13601ET024078   License Plate: KA47M3663
Mileage: 62340km-38736mi   Repair Order: Ciclo 2+Edit



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 60 (7E0)
Scan: 01 03 04 08 09 10 15 17 19 25 44 56 0B

VIN: WVWJ13601ET024078   Mileage: 62340km-38736miles

01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
56-Radio -- Status: OK 0000
 
-------------------------------------------------------------------------------
Address 01: Engine (J623-CLNA)       Labels: 03L-906-023-CAY.clb
   Part No SW: 03L 906 023 NT    HW: 03L 907 425 B
   Component: 1,6l R4 CR td H33 9971  
   Revision: --H33---    Serial number: 00000000000000
   Coding: 00110016032500080000
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_ECM16TDI02103L906023NT 003012
   ROD: EV_ECM16TDI02103L906023MJ.rod
   VCID: 05064A5684BA6669DA-8050

No fault code found.
Readiness: 1000 1000

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels: Redir Fail!
   Part No SW: 6R0 907 379 BF    HW: 6R0 907 379 AQ
   Component: ABS9.0 front  H01 0001  
   Serial number: --------------
   Coding: 60DD2F63212504C40614F470845920020000
   Shop #: WSC 57830 002 1048576
   ASAM Dataset: EV_Brake1ABS90BOSCH 003017
   ROD: EV_Brake1ABS90BOSCH_VW25.rod
   VCID: 0302544E8A8E5859F4-8056

No fault code found.

-------------------------------------------------------------------------------
Address 04: Steering Angle (G085)       Labels: 6R0-959-654.clb
   Part No SW: 6R0 959 654     HW: 6R0 959 654 
   Component: LENKW.SENSOR  H07 0070  
   Serial number: 23101713470492
   Coding: 01
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_LWSKLOVW25X 005001
   ROD: EV_LWSKLOVW25X.rod
   VCID: 7EF425BAE16C35B19B-802A

1 Fault Found:
1140738 - Steering angle sensor 
          B1168 54 [009] - Missing Calibration / Basic Setting
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 7
                    Mileage: 62345 km
                    Date: 2016.01.30
                    Time: 23:27:35

                    Voltage terminal 15: 11.70 V
                    Voltage terminal 30: 12.05 V
                    Terminal 15 status: On


-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels: 6R0-907-044.clb
   Part No SW: 6R0 907 044 L    HW: 6R0 907 044 L
   Component: Climatronic   H12 0612  
   Revision: V0000000    
   VCID: 3C70EFB2BFF0E7A1F5-8068

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels: 7E0-937-BCM-V1.clb
   Part No SW: 7E0 937 090 C    HW: 7E0 937 090 C
   Component: BCM PQ25 Max4 H82 0752  
   Revision: B9082001    Serial number: 4000 320170423
   Coding: 3A904BBF48A10000013807006CCB96900080676F60CD39E1210000030020
   Shop #: WSC 00788 648 00255
   VCID: 2B52DCEE4A9E70196C-807E

   Subsystem 1 - Part No: 5K7 955 559 C  Labels: 5K7-955-559.CLB
   Component: RLS 230118 04  47  0106 
   Coding: 0728DD

   Subsystem 2 - Part No SW: 6R0 959 802 AL    HW: 6R0 959 802 AL  Labels: 6R0-959-802.CLB
   Component: -------------  006 5520 
   Serial number: 13202576130625091059
   Coding: 010000

   Subsystem 3 - Part No SW: 6R0 959 801 AH    HW: 6R0 959 801 AH  Labels: 6R0-959-801.CLB
   Component: -------------  006 5520 
   Serial number: 13102579130618031221
   Coding: 010000

   Subsystem 4 - Part No SW: 6C0 959 442     HW: 6C0 959 442 
   Component: E221__MFL-TAT  H04 0019 
   Serial number: 2671409414901055AB1B
   Coding: 240000

   Subsystem 5 - Part No SW: 6R0 959 811 L    HW: 6R0 959 811 L
   Component: -------------  006 5520 
   Serial number: 13102580130620031450
   Coding: 020000

   Subsystem 6 - Part No SW: 6R0 959 812 L    HW: 6R0 959 812 L
   Component: -------------  006 5520 
   Serial number: 13102581130620063454
   Coding: 020000

No fault code found.

-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446)       Labels: 6R0-919-475.clb
   Part No SW: 6R0 919 475 C    HW: 7E0 919 475 
   Component: PARKHILFE 4K  H11 0013  
   Revision: --------    Serial number: 47361317300143
   Coding: 108002
   Shop #: WSC 00793 648 00255
   ASAM Dataset: EV_VW250ParkiAssis2 S01008
   ROD: EV_VW250ParkiAssis2.rod
   VCID: 3E74E5BAA1ECF5B1DB-806A

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels: 5K0-959-655.clb
   Part No SW: 6R0 959 655 J    HW: 6R0 959 655 J
   Component: VW10AirbagU06 H10 0020  
   Revision: --------    Serial number: 003GW00M0RR+
   Coding: 003036
   Shop #: WSC 01383 785 00200
   ASAM Dataset: EV_AirbaVW10BPAVW250 A01001
   ROD: EV_AirbaVW10BPAVW250_VW25.rod
   VCID: 499E8666E82242097E-801C

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels: 5K0-920-xxx-17.clb
   Part No SW: 6RF 920 862     HW: 6RF 920 862 
   Component: KOMBI         H01 0214  
   Serial number: 00000000000000
   Coding: 140A000000
   Shop #: WSC 13202 938 00000
   ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A05729
   ROD: EV_Kombi_UDS_VDD_RM09_004_VW25.rod
   VCID: 091E4666A8A20209BE-805C

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels: None
   Part No SW: 7E0 909 901     HW: 7E0 937 090 C
   Component: GW-K-CAN TP20 H82 0752  
   Revision: B9082001    
   Coding: 002300
   Shop #: WSC 00788 648 00255
   VCID: 68D863E29BE89B0141-803C

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels: 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5K0 953 234 
   Component: IMMO          H01 0214  
   Serial number:               
   Coding: 000000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03710
   ROD: EV_Immo_UDS_VDD_RM09_VW21.rod
   VCID: 6ADC19EA8DE4A91157-803E

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist (J792)       Labels: 6Rx-909-144-V1.clb
   Part No SW: 6RF 909 144 K    HW: 6RF 909 144 J
   Component: EPS_ECU       H44 0401  
   Coding: 0000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_SteerAssisUDSNSK 005005
   ROD: EV_SteerAssisUDSNSK_SK26.rod
   VCID: 54A0A7123F600FE11D-8000

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (J503)       Labels: None
   Part No SW: 6RD 035 187 B    HW: 6RD 035 187 B
   Component: Radio         534 5314  
   Revision: --------    Serial number: VWZZZ4H6267388
   Coding: 16000440040005
   Shop #: WSC 127395 840 08317
   VCID: 46848D5AF13CAD7193-8012

No fault code found.

End-------------------------(Elapsed Time: 02:44)--------------------------
Any test missing please let me know.

User avatar
iichel
Bling Bling Diamond Member
Posts: 2844
Joined: Fri Nov 14, 2014 2:14 pm
Drives: Polo 6R 1.2 TDI
Location: kessiichel is everywhere :)

Re: Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Post by iichel » Thu May 17, 2018 8:04 pm

3A904BBF48A10000013807006CCB96900080676F60CF39E1210000030020

maybe this makes your parking lights work, but at full brightness instead of 100%
just use it as temporary solution until the correct BCM arrives of course

User avatar
ciclo
Bling Bling Diamond Member
Posts: 4363
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R '13
Location: Earth ♥, Spain ☼
Contact:

Re: Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Post by ciclo » Fri May 18, 2018 6:01 am

vento2013 wrote:
Thu May 17, 2018 7:26 pm
ciclo wrote:
Thu May 17, 2018 5:39 pm
3A904BBF48A10000013807006CCB96900080606F60CD39E1210000030020

I have made small change in code
3A904BBF48A10000013807006CCB96900080676F60CD39E1210000030020

DRL = OK
Pass Light = OK (Only High beam)
Parking light = OK (When Headlight is on parking is OFF) Need Specific BCM.
Low Beam = OK
High Beam = OK
Fog Lights = OK (Parking goes OFF)
Static Cornering = OK Working perfectly
CH/LH = OK

Code: Select all

Thursday,17,May,2018,23:30:50:39744
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x86
VCDS Version: 17.1.3.0
Data version: 20170220 DS267.3
www.Ross-Tech.com


VIN: WVWJ13601ET024078   License Plate: KA47M3663
Mileage: 62340km-38736mi   Repair Order: Ciclo 2+Edit



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 60 (7E0)
Scan: 01 03 04 08 09 10 15 17 19 25 44 56 0B

VIN: WVWJ13601ET024078   Mileage: 62340km-38736miles

01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
56-Radio -- Status: OK 0000
 
-------------------------------------------------------------------------------
Address 01: Engine (J623-CLNA)       Labels: 03L-906-023-CAY.clb
   Part No SW: 03L 906 023 NT    HW: 03L 907 425 B
   Component: 1,6l R4 CR td H33 9971  
   Revision: --H33---    Serial number: 00000000000000
   Coding: 00110016032500080000
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_ECM16TDI02103L906023NT 003012
   ROD: EV_ECM16TDI02103L906023MJ.rod
   VCID: 05064A5684BA6669DA-8050

No fault code found.
Readiness: 1000 1000

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels: Redir Fail!
   Part No SW: 6R0 907 379 BF    HW: 6R0 907 379 AQ
   Component: ABS9.0 front  H01 0001  
   Serial number: --------------
   Coding: 60DD2F63212504C40614F470845920020000
   Shop #: WSC 57830 002 1048576
   ASAM Dataset: EV_Brake1ABS90BOSCH 003017
   ROD: EV_Brake1ABS90BOSCH_VW25.rod
   VCID: 0302544E8A8E5859F4-8056

No fault code found.

-------------------------------------------------------------------------------
Address 04: Steering Angle (G085)       Labels: 6R0-959-654.clb
   Part No SW: 6R0 959 654     HW: 6R0 959 654 
   Component: LENKW.SENSOR  H07 0070  
   Serial number: 23101713470492
   Coding: 01
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_LWSKLOVW25X 005001
   ROD: EV_LWSKLOVW25X.rod
   VCID: 7EF425BAE16C35B19B-802A

1 Fault Found:
1140738 - Steering angle sensor 
          B1168 54 [009] - Missing Calibration / Basic Setting
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 7
                    Mileage: 62345 km
                    Date: 2016.01.30
                    Time: 23:27:35

                    Voltage terminal 15: 11.70 V
                    Voltage terminal 30: 12.05 V
                    Terminal 15 status: On


-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels: 6R0-907-044.clb
   Part No SW: 6R0 907 044 L    HW: 6R0 907 044 L
   Component: Climatronic   H12 0612  
   Revision: V0000000    
   VCID: 3C70EFB2BFF0E7A1F5-8068

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels: 7E0-937-BCM-V1.clb
   Part No SW: 7E0 937 090 C    HW: 7E0 937 090 C
   Component: BCM PQ25 Max4 H82 0752  
   Revision: B9082001    Serial number: 4000 320170423
   Coding: 3A904BBF48A10000013807006CCB96900080676F60CD39E1210000030020
   Shop #: WSC 00788 648 00255
   VCID: 2B52DCEE4A9E70196C-807E

   Subsystem 1 - Part No: 5K7 955 559 C  Labels: 5K7-955-559.CLB
   Component: RLS 230118 04  47  0106 
   Coding: 0728DD

   Subsystem 2 - Part No SW: 6R0 959 802 AL    HW: 6R0 959 802 AL  Labels: 6R0-959-802.CLB
   Component: -------------  006 5520 
   Serial number: 13202576130625091059
   Coding: 010000

   Subsystem 3 - Part No SW: 6R0 959 801 AH    HW: 6R0 959 801 AH  Labels: 6R0-959-801.CLB
   Component: -------------  006 5520 
   Serial number: 13102579130618031221
   Coding: 010000

   Subsystem 4 - Part No SW: 6C0 959 442     HW: 6C0 959 442 
   Component: E221__MFL-TAT  H04 0019 
   Serial number: 2671409414901055AB1B
   Coding: 240000

   Subsystem 5 - Part No SW: 6R0 959 811 L    HW: 6R0 959 811 L
   Component: -------------  006 5520 
   Serial number: 13102580130620031450
   Coding: 020000

   Subsystem 6 - Part No SW: 6R0 959 812 L    HW: 6R0 959 812 L
   Component: -------------  006 5520 
   Serial number: 13102581130620063454
   Coding: 020000

No fault code found.

-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446)       Labels: 6R0-919-475.clb
   Part No SW: 6R0 919 475 C    HW: 7E0 919 475 
   Component: PARKHILFE 4K  H11 0013  
   Revision: --------    Serial number: 47361317300143
   Coding: 108002
   Shop #: WSC 00793 648 00255
   ASAM Dataset: EV_VW250ParkiAssis2 S01008
   ROD: EV_VW250ParkiAssis2.rod
   VCID: 3E74E5BAA1ECF5B1DB-806A

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels: 5K0-959-655.clb
   Part No SW: 6R0 959 655 J    HW: 6R0 959 655 J
   Component: VW10AirbagU06 H10 0020  
   Revision: --------    Serial number: 003GW00M0RR+
   Coding: 003036
   Shop #: WSC 01383 785 00200
   ASAM Dataset: EV_AirbaVW10BPAVW250 A01001
   ROD: EV_AirbaVW10BPAVW250_VW25.rod
   VCID: 499E8666E82242097E-801C

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels: 5K0-920-xxx-17.clb
   Part No SW: 6RF 920 862     HW: 6RF 920 862 
   Component: KOMBI         H01 0214  
   Serial number: 00000000000000
   Coding: 140A000000
   Shop #: WSC 13202 938 00000
   ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A05729
   ROD: EV_Kombi_UDS_VDD_RM09_004_VW25.rod
   VCID: 091E4666A8A20209BE-805C

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels: None
   Part No SW: 7E0 909 901     HW: 7E0 937 090 C
   Component: GW-K-CAN TP20 H82 0752  
   Revision: B9082001    
   Coding: 002300
   Shop #: WSC 00788 648 00255
   VCID: 68D863E29BE89B0141-803C

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels: 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5K0 953 234 
   Component: IMMO          H01 0214  
   Serial number:               
   Coding: 000000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03710
   ROD: EV_Immo_UDS_VDD_RM09_VW21.rod
   VCID: 6ADC19EA8DE4A91157-803E

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist (J792)       Labels: 6Rx-909-144-V1.clb
   Part No SW: 6RF 909 144 K    HW: 6RF 909 144 J
   Component: EPS_ECU       H44 0401  
   Coding: 0000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_SteerAssisUDSNSK 005005
   ROD: EV_SteerAssisUDSNSK_SK26.rod
   VCID: 54A0A7123F600FE11D-8000

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (J503)       Labels: None
   Part No SW: 6RD 035 187 B    HW: 6RD 035 187 B
   Component: Radio         534 5314  
   Revision: --------    Serial number: VWZZZ4H6267388
   Coding: 16000440040005
   Shop #: WSC 127395 840 08317
   VCID: 46848D5AF13CAD7193-8012

No fault code found.

End-------------------------(Elapsed Time: 02:44)--------------------------

No small change, it's a big change. (changes are made in several parameters)
If at the moment you are happy with this lights operation, me too. :)
This BCM coding is for Vento LED Headlights, in the same way like factory coding. (except Byte18)

We'll wait for your new BCM 8IT for LED headlights.

vento2013 wrote:
Thu May 17, 2018 7:26 pm
Any test missing please let me know.
Well, just for curiosity ...

Try the following Hexadecimals and with the following order in the Byte18 of your current BCM 8IG for Bixenon headlights.

61
62
63
64
65
66

and tell us in which of them the SCLs start to work. (64?)

vento2013
New
Posts: 49
Joined: Fri Mar 02, 2018 8:44 am
Drives: 6R Polo(Vento)1.6TDi, Skoda Fabia 1.2MPi
Location: India

Re: Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Post by vento2013 » Sat May 19, 2018 3:23 pm

Sorry was bit busy. So now replying.

Just now checked Hexadecimals and with the following order in the Byte 18, 61 to 66 result are

Byte 18 changed value to 61, 62, 63
DRL = OK
Pass Light = OK (Only High beam)
Parking light = OK (When Headlight is on parking is OFF) Need Specific BCM.
Low Beam = OK
High Beam = OK
Fog Lights = OK (Parking goes OFF)
Static Cornering = Not working

Byte 18 changed value to 64
DRL = OK
Pass Light = Not OK (High beam+Low Beam)
Parking light = OK (When Headlight is on parking is OFF) Need Specific BCM.
Low Beam = OK
High Beam = OK
Fog Lights = OK (Parking goes OFF)
Static Cornering = Ok

Byte 18 changed value to 65, 66
DRL = OK
Pass Light = OK (Only High beam)
Parking light = OK (When Headlight is on parking is OFF) Need Specific BCM.
Low Beam = OK
High Beam = OK
Fog Lights = OK (Parking goes OFF)
Static Cornering = Ok

now in Byte 18 value is 66
scan report

Code: Select all

Saturday,19,May,2018,19:13:01:39744
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x86
VCDS Version: 17.1.3.0
Data version: 20170220 DS267.3
www.Ross-Tech.com


VIN: WVWJ13601ET024078   License Plate: KA47M3663
Mileage: 62340km-38736mi   Repair Order: coding66


Chassis Type: 60 (7E0)
Scan: 01 03 04 08 09 10 15 17 19 25 44 56 0B

VIN: WVWJ13601ET024078   Mileage: 62340km-38736miles

01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
56-Radio -- Status: OK 0000
 
-------------------------------------------------------------------------------
Address 01: Engine (J623-CLNA)       Labels: 03L-906-023-CAY.clb
   Part No SW: 03L 906 023 NT    HW: 03L 907 425 B
   Component: 1,6l R4 CR td H33 9971  
   Revision: --H33---    Serial number: 00000000000000
   Coding: 00110016032500080000
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_ECM16TDI02103L906023NT 003012
   ROD: EV_ECM16TDI02103L906023MJ.rod
   VCID: 05064A5684BA6669DA-8050

No fault code found.
Readiness: 0000 1000

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels: Redir Fail!
   Part No SW: 6R0 907 379 BF    HW: 6R0 907 379 AQ
   Component: ABS9.0 front  H01 0001  
   Serial number: --------------
   Coding: 60DD2F63212504C40614F470845920020000
   Shop #: WSC 57830 002 1048576
   ASAM Dataset: EV_Brake1ABS90BOSCH 003017
   ROD: EV_Brake1ABS90BOSCH_VW25.rod
   VCID: 0302544E8A8E5859F4-8056

No fault code found.

-------------------------------------------------------------------------------
Address 04: Steering Angle (G085)       Labels: 6R0-959-654.clb
   Part No SW: 6R0 959 654     HW: 6R0 959 654 
   Component: LENKW.SENSOR  H07 0070  
   Serial number: 23101713470492
   Coding: 01
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_LWSKLOVW25X 005001
   ROD: EV_LWSKLOVW25X.rod
   VCID: 7EF425BAE16C35B19B-802A

1 Fault Found:
1140738 - Steering angle sensor 
          B1168 54 [009] - Missing Calibration / Basic Setting
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 7
                    Mileage: 62345 km
                    Date: 2016.01.30
                    Time: 23:27:35

                    Voltage terminal 15: 11.70 V
                    Voltage terminal 30: 12.05 V
                    Terminal 15 status: On


-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels: 6R0-907-044.clb
   Part No SW: 6R0 907 044 L    HW: 6R0 907 044 L
   Component: Climatronic   H12 0612  
   Revision: V0000000    
   VCID: 3C70EFB2BFF0E7A1F5-8068

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels: 7E0-937-BCM-V1.clb
   Part No SW: 7E0 937 090 C    HW: 7E0 937 090 C
   Component: BCM PQ25 Max4 H82 0752  
   Revision: B9082001    Serial number: 4000 320170423
   Coding: 3A904BBF48A10000013807006CCB96900080666F60CD39E1210000030020
   Shop #: WSC 00788 648 00255
   VCID: 2B52DCEE4A9E70196C-807E

   Subsystem 1 - Part No: 5K7 955 559 C  Labels: 5K7-955-559.CLB
   Component: RLS 230118 04  47  0106 
   Coding: 0728DD

   Subsystem 2 - Part No SW: 6R0 959 802 AL    HW: 6R0 959 802 AL  Labels: 6R0-959-802.CLB
   Component: -------------  006 5520 
   Serial number: 13202576130625091059
   Coding: 010000

   Subsystem 3 - Part No SW: 6R0 959 801 AH    HW: 6R0 959 801 AH  Labels: 6R0-959-801.CLB
   Component: -------------  006 5520 
   Serial number: 13102579130618031221
   Coding: 010000

   Subsystem 4 - Part No SW: 6C0 959 442     HW: 6C0 959 442 
   Component: E221__MFL-TAT  H04 0019 
   Serial number: 2671409414901055AB1B
   Coding: 240000

   Subsystem 5 - Part No SW: 6R0 959 811 L    HW: 6R0 959 811 L
   Component: -------------  006 5520 
   Serial number: 13102580130620031450
   Coding: 020000

   Subsystem 6 - Part No SW: 6R0 959 812 L    HW: 6R0 959 812 L
   Component: -------------  006 5520 
   Serial number: 13102581130620063454
   Coding: 020000

No fault code found.

-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446)       Labels: 6R0-919-475.clb
   Part No SW: 6R0 919 475 C    HW: 7E0 919 475 
   Component: PARKHILFE 4K  H11 0013  
   Revision: --------    Serial number: 47361317300143
   Coding: 108002
   Shop #: WSC 00793 648 00255
   ASAM Dataset: EV_VW250ParkiAssis2 S01008
   ROD: EV_VW250ParkiAssis2.rod
   VCID: 3E74E5BAA1ECF5B1DB-806A

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels: 5K0-959-655.clb
   Part No SW: 6R0 959 655 J    HW: 6R0 959 655 J
   Component: VW10AirbagU06 H10 0020  
   Revision: --------    Serial number: 003GW00M0RR+
   Coding: 003036
   Shop #: WSC 01383 785 00200
   ASAM Dataset: EV_AirbaVW10BPAVW250 A01001
   ROD: EV_AirbaVW10BPAVW250_VW25.rod
   VCID: 499E8666E82242097E-801C

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels: 5K0-920-xxx-17.clb
   Part No SW: 6RF 920 862     HW: 6RF 920 862 
   Component: KOMBI         H01 0214  
   Serial number: 00000000000000
   Coding: 140A000000
   Shop #: WSC 13202 938 00000
   ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A05729
   ROD: EV_Kombi_UDS_VDD_RM09_004_VW25.rod
   VCID: 091E4666A8A20209BE-805C

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels: None
   Part No SW: 7E0 909 901     HW: 7E0 937 090 C
   Component: GW-K-CAN TP20 H82 0752  
   Revision: B9082001    
   Coding: 002300
   Shop #: WSC 00788 648 00255
   VCID: 68D863E29BE89B0141-803C

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels: 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5K0 953 234 
   Component: IMMO          H01 0214  
   Serial number:               
   Coding: 000000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03710
   ROD: EV_Immo_UDS_VDD_RM09_VW21.rod
   VCID: 6ADC19EA8DE4A91157-803E

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist (J792)       Labels: 6Rx-909-144-V1.clb
   Part No SW: 6RF 909 144 K    HW: 6RF 909 144 J
   Component: EPS_ECU       H44 0401  
   Coding: 0000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_SteerAssisUDSNSK 005005
   ROD: EV_SteerAssisUDSNSK_SK26.rod
   VCID: 54A0A7123F600FE11D-8000

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (J503)       Labels: None
   Part No SW: 6RD 035 187 B    HW: 6RD 035 187 B
   Component: Radio         534 5314  
   Revision: --------    Serial number: VWZZZ4H6267388
   Coding: 16000440040005
   Shop #: WSC 127395 840 08317
   VCID: 46848D5AF13CAD7193-8012

No fault code found.

End-------------------------(Elapsed Time: 02:41)--------------------------
One more weird thing noticed with this coding
3A904BBF48A10000013807006CCB96900080606F60CD39E1210000030020
or
3A904BBF48A10000013807006CCB96900080676F60CD39E1210000030020
Reverse camera used to flicker a lot(attached image) I do not use reverse camera much, I prefer parking sensor with acoustic sound so I never bothered about camera.
Screenshot_20180519-192707~2.png
But with this new coding
3A904BBF48A10000013807006CCB96900080666F60CD39E1210000030020
camera is not flickering I am not sure how it is related to this. What I noticed just sharing it here.

User avatar
ciclo
Bling Bling Diamond Member
Posts: 4363
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R '13
Location: Earth ♥, Spain ☼
Contact:

Re: Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Post by ciclo » Sat May 19, 2018 6:25 pm

Wow! good report! 8) ... it's what I supposed.
Many thanks.

As I told you, it was not a small change. The BCM Byte18 modifies the way it feeds the BCM pins for the lights. Also the diagnosis.
You must bear in mind that this 7E0... C BCM is parameterized for Bixenon headlights, while the headlights you have installed are LED.

We are preparing a good coding for your new 7E0 BCM for LED headlights and rest of devices.
vento2013 wrote:
Sat May 19, 2018 3:23 pm
now in Byte 18 value is 66
Logically. Image

vento2013
New
Posts: 49
Joined: Fri Mar 02, 2018 8:44 am
Drives: 6R Polo(Vento)1.6TDi, Skoda Fabia 1.2MPi
Location: India

Re: Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Post by vento2013 » Mon Jun 04, 2018 8:27 am

Hi, Ciclo Finally BCM for LED headlights arrived.
just now swapped BCM n result is...

DRL = OK
Pass Light(Flashing) = OK
Parking light = OK
Low Beam = OK
High Beam = OK
Fog Lights = OK
Static Cornering = Partially working(only Left side working)

VCDS scan report

Code: Select all

Monday,04,June,2018,12:26:49:39744
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x86
VCDS Version: 17.1.3.0
Data version: 20170220 DS267.3
www.Ross-Tech.com

VIN: WVWJ13601ET024078   License Plate: KA47M3663
Mileage:    Repair Order: 04062018 8ITBCM

--------------------------------------------------------------------------------
--------------------------------------------------------------------------------

Chassis Type: 60 (7E0)
Scan: 01 03 04 08 09 10 15 17 19 25 44 56 0B

VIN: WVWJ13601ET024078   

01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
56-Radio -- Status: OK 0000
 
-------------------------------------------------------------------------------
Address 01: Engine (J623-CLNA)       Labels: 03L-906-023-CAY.clb
   Part No SW: 03L 906 023 NT    HW: 03L 907 425 B
   Component: 1,6l R4 CR td H33 9971  
   Revision: --H33---    Serial number: 00000000000000
   Coding: 00110016032500080000
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_ECM1T6DI02103L906023NT 003012
   ROD: N/A
   VCID: 05064A5684BA6669DA-8050

No ASAM data for: "EV_ECM1T6DI02103L906023NT" (VW36 *) 
No fault code found.
Readiness: 0000 1000

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels: Redir Fail!
   Part No SW: 6R0 907 379 BF    HW: 6R0 907 379 AQ
   Component: ABS9.0 front  H01 0001  
   Serial number: --------------
   Coding: 60DD2F63212504C40614F470845920020000
   Shop #: WSC 57830 002 1048576
   ASAM Dataset: EV_Brake1AB9S0BOSCH 003017
   ROD: N/A
   VCID: 0302544E8A8E5859F4-8056

No ASAM data for: "EV_Brake1AB9S0BOSCH" (VW25) 
No fault code found.

-------------------------------------------------------------------------------
Address 04: Steering Angle (G085)       Labels: 6R0-959-654.clb
   Part No SW: 6R0 959 654     HW: 6R0 959 654 
   Component: LENKW.SENSOR  H07 0070  
   Serial number: 23101713470492
   Coding: 01
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_LWSKLOVW52X 005001
   ROD: N/A
   VCID: 7EF425BAE16C35B19B-802A

No ASAM data for: "EV_LWSKLOVW52X" (VW25) 
1 Fault Found:
1140738 - ROD - Unknown Error Code 
          - 00 [009]
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 12
                    Mileage: 62403 km
                    Date: 2016.02.17
                    Time: 00:38:22


-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels: 6R0-907-044.clb
   Part No SW: 6R0 907 044 L    HW: 6R0 907 044 L
   Component: Climatronic   H12 0612  
   Revision: V0000000    
   VCID: 3C70EFB2BFF0E7A1F5-8068

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels: 7E0-937-BCM-V1.clb
   Part No SW: 7E0 937 090 C    HW: 7E0 937 090 C
   Component: BCM PQ25 Max4 H82 0752  
   Revision: B9082001    Serial number: 4000 173170900
   Coding: 3A904BBF48A10000013807006CCB96900080606F60CD39E1210000030020
   Shop #: WSC 12345 123 12345
   VCID: 2B52DCEE4A9E70196C-807E

   Subsystem 1 - Part No: 5K7 955 559 C  Labels: 5K7-955-559.CLB
   Component: RLS 230118 04  47  0106 
   Coding: 0728DD

   Subsystem 2 - Part No SW: 6R0 959 802 AL    HW: 6R0 959 802 AL  Labels: 6R0-959-802.CLB
   Component: -------------  006 5520 
   Serial number: 13202576130625091059
   Coding: 010000

   Subsystem 3 - Part No SW: 6R0 959 801 AH    HW: 6R0 959 801 AH  Labels: 6R0-959-801.CLB
   Component: -------------  006 5520 
   Serial number: 13102579130618031221
   Coding: 010000

   Subsystem 4 - Part No SW: 6C0 959 442     HW: 6C0 959 442 
   Component: E221__MFL-TAT  H04 0019 
   Serial number: 2671409414901055AB1B
   Coding: 240000

   Subsystem 5 - Part No SW: 6R0 959 811 L    HW: 6R0 959 811 L
   Component: -------------  006 5520 
   Serial number: 13102580130620031450
   Coding: 020000

   Subsystem 6 - Part No SW: 6R0 959 812 L    HW: 6R0 959 812 L
   Component: -------------  006 5520 
   Serial number: 13102581130620063454
   Coding: 020000

2 Faults Found:
00978 - Lamp for Low Beam; Left (M29) 
            010 - Open or Short to Plus
             Freeze Frame:
                    Fault Status: 01101010
                    Fault Priority: 3
                    Fault Frequency: 224
                    Reset counter: 12
                    Mileage: 62403 km
                    Time Indication: 0
                    Date: 2016.02.17
                    Time: 00:39:37

00979 - Lamp for Low Beam; Right (M31) 
            010 - Open or Short to Plus
             Freeze Frame:
                    Fault Status: 01101010
                    Fault Priority: 3
                    Fault Frequency: 224
                    Reset counter: 12
                    Mileage: 62403 km
                    Time Indication: 0
                    Date: 2016.02.17
                    Time: 00:39:37


-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446)       Labels: 6R0-919-475.clb
   Part No SW: 6R0 919 475 C    HW: 7E0 919 475 
   Component: PARKHILFE 4K  H11 0013  
   Revision: --------    Serial number: 47361317300143
   Coding: 108002
   Shop #: WSC 00793 648 00255
   ASAM Dataset: EV_VW250ParkiAssis2 S01008
   ROD: EV_VW250ParkiAssis2.rod
   VCID: 3E74E5BAA1ECF5B1DB-806A

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels: 5K0-959-655.clb
   Part No SW: 6R0 959 655 J    HW: 6R0 959 655 J
   Component: VW10AirbagU06 H10 0020  
   Revision: --------    Serial number: 003GW00M0RR+
   Coding: 003036
   Shop #: WSC 01383 785 00200
   ASAM Dataset: EV_AibraVW10BPAVW250 A01001
   ROD: N/A
   VCID: 499E8666E82242097E-801C

No ASAM data for: "EV_AibraVW10BPAVW250" (VW25) 
No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels: 5K0-920-xxx-17.clb
   Part No SW: 6RF 920 862     HW: 6RF 920 862 
   Component: KOMBI         H01 0214  
   Serial number: 00000000000000
   Coding: 140A000000
   Shop #: WSC 13202 938 00000
   ASAM Dataset: EV_Kobmi_UDS_VDD_RM09 A05729
   ROD: N/A
   VCID: 091E4666A8A20209BE-805C

No ASAM data for: "EV_Kobmi_UDS_VDD_RM09" (VW36 *) 
No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels: None
   Part No SW: 7E0 909 901     HW: 7E0 937 090 C
   Component: GW-K-CAN TP20 H82 0752  
   Revision: B9082001    
   Coding: 102300
   Shop #: WSC 12345 123 12345
   VCID: 68D863E29BE89B0141-803C

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels: 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5K0 953 234 
   Component: IMMO          H01 0214  
   Serial number:               
   Coding: 000000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_Mimo_UDS_VDD_RM09 A03710
   ROD: N/A
   VCID: 6ADC19EA8DE4A91157-803E

No ASAM data for: "EV_Mimo_UDS_VDD_RM09" (VW36 *) 
No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist (J792)       Labels: 6Rx-909-144-V1.clb
   Part No SW: 6RF 909 144 K    HW: 6RF 909 144 J
   Component: EPS_ECU       H44 0401  
   Coding: 0000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_SteerAsissUDSNSK 005005
   ROD: N/A
   VCID: 54A0A7123F600FE11D-8000

No ASAM data for: "EV_SteerAsissUDSNSK" (VW25) 
No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (J503)       Labels: None
   Part No SW: 6RD 035 187 B    HW: 6RD 035 187 B
   Component: Radio         534 5314  
   Revision: --------    Serial number: VWZZZ4H6267388
   Coding: 16000440040005
   Shop #: WSC 127395 840 08317
   VCID: 46848D5AF13CAD7193-8012

No fault code found.

End-------------------------(Elapsed Time: 02:41)--------------------------

User avatar
iichel
Bling Bling Diamond Member
Posts: 2844
Joined: Fri Nov 14, 2014 2:14 pm
Drives: Polo 6R 1.2 TDI
Location: kessiichel is everywhere :)

Re: Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Post by iichel » Mon Jun 04, 2018 10:12 am

I'm afraid the low beam errors will only go away if you have the correct BCM; coding it will not work.
I think the value ciclo wrote for byte 18 (HEX 66) is indeed the correct one for your configuration but you could try 60 and 73. But I don't think it will make a difference.

User avatar
ciclo
Bling Bling Diamond Member
Posts: 4363
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R '13
Location: Earth ♥, Spain ☼
Contact:

Re: Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Post by ciclo » Mon Jun 04, 2018 12:50 pm

vento2013 wrote:
Mon Jun 04, 2018 8:27 am
Hi, Ciclo Finally BCM for LED headlights arrived.
just now swapped BCM n result is...

DRL = OK
Pass Light(Flashing) = OK
Parking light = OK
Low Beam = OK
High Beam = OK
Fog Lights = OK
Static Cornering = Partially working(only Left side working)

VCDS scan report

Code: Select all

Monday,04,June,2018,12:26:49:39744
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x86
VCDS Version: 17.1.3.0
Data version: 20170220 DS267.3
www.Ross-Tech.com

VIN: WVWJ13601ET024078   License Plate: KA47M3663
Mileage:    Repair Order: 04062018 8ITBCM

--------------------------------------------------------------------------------
--------------------------------------------------------------------------------

Chassis Type: 60 (7E0)
Scan: 01 03 04 08 09 10 15 17 19 25 44 56 0B

VIN: WVWJ13601ET024078   

01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
56-Radio -- Status: OK 0000
 
-------------------------------------------------------------------------------
Address 01: Engine (J623-CLNA)       Labels: 03L-906-023-CAY.clb
   Part No SW: 03L 906 023 NT    HW: 03L 907 425 B
   Component: 1,6l R4 CR td H33 9971  
   Revision: --H33---    Serial number: 00000000000000
   Coding: 00110016032500080000
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_ECM1T6DI02103L906023NT 003012
   ROD: N/A
   VCID: 05064A5684BA6669DA-8050

No ASAM data for: "EV_ECM1T6DI02103L906023NT" (VW36 *) 
No fault code found.
Readiness: 0000 1000

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels: Redir Fail!
   Part No SW: 6R0 907 379 BF    HW: 6R0 907 379 AQ
   Component: ABS9.0 front  H01 0001  
   Serial number: --------------
   Coding: 60DD2F63212504C40614F470845920020000
   Shop #: WSC 57830 002 1048576
   ASAM Dataset: EV_Brake1AB9S0BOSCH 003017
   ROD: N/A
   VCID: 0302544E8A8E5859F4-8056

No ASAM data for: "EV_Brake1AB9S0BOSCH" (VW25) 
No fault code found.

-------------------------------------------------------------------------------
Address 04: Steering Angle (G085)       Labels: 6R0-959-654.clb
   Part No SW: 6R0 959 654     HW: 6R0 959 654 
   Component: LENKW.SENSOR  H07 0070  
   Serial number: 23101713470492
   Coding: 01
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_LWSKLOVW52X 005001
   ROD: N/A
   VCID: 7EF425BAE16C35B19B-802A

No ASAM data for: "EV_LWSKLOVW52X" (VW25) 
1 Fault Found:
1140738 - ROD - Unknown Error Code 
          - 00 [009]
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 12
                    Mileage: 62403 km
                    Date: 2016.02.17
                    Time: 00:38:22


-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels: 6R0-907-044.clb
   Part No SW: 6R0 907 044 L    HW: 6R0 907 044 L
   Component: Climatronic   H12 0612  
   Revision: V0000000    
   VCID: 3C70EFB2BFF0E7A1F5-8068

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels: 7E0-937-BCM-V1.clb
   Part No SW: 7E0 937 090 C    HW: 7E0 937 090 C
   Component: BCM PQ25 Max4 H82 0752  
   Revision: B9082001    Serial number: 4000 173170900
   Coding: 3A904BBF48A10000013807006CCB96900080606F60CD39E1210000030020
   Shop #: WSC 12345 123 12345
   VCID: 2B52DCEE4A9E70196C-807E

   Subsystem 1 - Part No: 5K7 955 559 C  Labels: 5K7-955-559.CLB
   Component: RLS 230118 04  47  0106 
   Coding: 0728DD

   Subsystem 2 - Part No SW: 6R0 959 802 AL    HW: 6R0 959 802 AL  Labels: 6R0-959-802.CLB
   Component: -------------  006 5520 
   Serial number: 13202576130625091059
   Coding: 010000

   Subsystem 3 - Part No SW: 6R0 959 801 AH    HW: 6R0 959 801 AH  Labels: 6R0-959-801.CLB
   Component: -------------  006 5520 
   Serial number: 13102579130618031221
   Coding: 010000

   Subsystem 4 - Part No SW: 6C0 959 442     HW: 6C0 959 442 
   Component: E221__MFL-TAT  H04 0019 
   Serial number: 2671409414901055AB1B
   Coding: 240000

   Subsystem 5 - Part No SW: 6R0 959 811 L    HW: 6R0 959 811 L
   Component: -------------  006 5520 
   Serial number: 13102580130620031450
   Coding: 020000

   Subsystem 6 - Part No SW: 6R0 959 812 L    HW: 6R0 959 812 L
   Component: -------------  006 5520 
   Serial number: 13102581130620063454
   Coding: 020000

2 Faults Found:
00978 - Lamp for Low Beam; Left (M29) 
            010 - Open or Short to Plus
             Freeze Frame:
                    Fault Status: 01101010
                    Fault Priority: 3
                    Fault Frequency: 224
                    Reset counter: 12
                    Mileage: 62403 km
                    Time Indication: 0
                    Date: 2016.02.17
                    Time: 00:39:37

00979 - Lamp for Low Beam; Right (M31) 
            010 - Open or Short to Plus
             Freeze Frame:
                    Fault Status: 01101010
                    Fault Priority: 3
                    Fault Frequency: 224
                    Reset counter: 12
                    Mileage: 62403 km
                    Time Indication: 0
                    Date: 2016.02.17
                    Time: 00:39:37


-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446)       Labels: 6R0-919-475.clb
   Part No SW: 6R0 919 475 C    HW: 7E0 919 475 
   Component: PARKHILFE 4K  H11 0013  
   Revision: --------    Serial number: 47361317300143
   Coding: 108002
   Shop #: WSC 00793 648 00255
   ASAM Dataset: EV_VW250ParkiAssis2 S01008
   ROD: EV_VW250ParkiAssis2.rod
   VCID: 3E74E5BAA1ECF5B1DB-806A

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels: 5K0-959-655.clb
   Part No SW: 6R0 959 655 J    HW: 6R0 959 655 J
   Component: VW10AirbagU06 H10 0020  
   Revision: --------    Serial number: 003GW00M0RR+
   Coding: 003036
   Shop #: WSC 01383 785 00200
   ASAM Dataset: EV_AibraVW10BPAVW250 A01001
   ROD: N/A
   VCID: 499E8666E82242097E-801C

No ASAM data for: "EV_AibraVW10BPAVW250" (VW25) 
No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels: 5K0-920-xxx-17.clb
   Part No SW: 6RF 920 862     HW: 6RF 920 862 
   Component: KOMBI         H01 0214  
   Serial number: 00000000000000
   Coding: 140A000000
   Shop #: WSC 13202 938 00000
   ASAM Dataset: EV_Kobmi_UDS_VDD_RM09 A05729
   ROD: N/A
   VCID: 091E4666A8A20209BE-805C

No ASAM data for: "EV_Kobmi_UDS_VDD_RM09" (VW36 *) 
No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels: None
   Part No SW: 7E0 909 901     HW: 7E0 937 090 C
   Component: GW-K-CAN TP20 H82 0752  
   Revision: B9082001    
   Coding: 102300
   Shop #: WSC 12345 123 12345
   VCID: 68D863E29BE89B0141-803C

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels: 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5K0 953 234 
   Component: IMMO          H01 0214  
   Serial number:               
   Coding: 000000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_Mimo_UDS_VDD_RM09 A03710
   ROD: N/A
   VCID: 6ADC19EA8DE4A91157-803E

No ASAM data for: "EV_Mimo_UDS_VDD_RM09" (VW36 *) 
No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist (J792)       Labels: 6Rx-909-144-V1.clb
   Part No SW: 6RF 909 144 K    HW: 6RF 909 144 J
   Component: EPS_ECU       H44 0401  
   Coding: 0000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_SteerAsissUDSNSK 005005
   ROD: N/A
   VCID: 54A0A7123F600FE11D-8000

No ASAM data for: "EV_SteerAsissUDSNSK" (VW25) 
No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (J503)       Labels: None
   Part No SW: 6RD 035 187 B    HW: 6RD 035 187 B
   Component: Radio         534 5314  
   Revision: --------    Serial number: VWZZZ4H6267388
   Coding: 16000440040005
   Shop #: WSC 127395 840 08317
   VCID: 46848D5AF13CAD7193-8012

No fault code found.

End-------------------------(Elapsed Time: 02:41)--------------------------
In this last autoscan the Byte18 is 60 HEX, change it to 66 HEX.

3A904BBF48A10000013807006CCB96900080666F60CD39E1210000030020

Tell us the result.

vento2013
New
Posts: 49
Joined: Fri Mar 02, 2018 8:44 am
Drives: 6R Polo(Vento)1.6TDi, Skoda Fabia 1.2MPi
Location: India

Re: Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Post by vento2013 » Mon Jun 04, 2018 7:33 pm

ciclo wrote:
Mon Jun 04, 2018 12:50 pm

In this last autoscan the Byte18 is 60 HEX, change it to 66 HEX.

3A904BBF48A10000013807006CCB96900080666F60CD39E1210000030020

Tell us the result.
Tried 66 in byte 18

DRL = OK
Pass Light(Flashing) = OK
Parking light = OK
Low Beam = OK
High Beam = OK
Fog Lights = OK
Static Cornering = OK
But new issue, when high beam is on right low beam flickers once in a while.

So now in byte 18 value is 60
and I turned off SCL.

this is my present coding
Coding: 3A904BBF48A10000013807002CCB96900080604F60C939E1210000030020
except SCL everything else perfect
have two fault codes

User avatar
ciclo
Bling Bling Diamond Member
Posts: 4363
Joined: Sun Feb 24, 2013 10:20 am
Drives: 6R '13
Location: Earth ♥, Spain ☼
Contact:

Re: Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Post by ciclo » Mon Jun 04, 2018 8:57 pm

Try 64 and 65 HEX in Byte18.
64
3A904BBF48A10000013807006CCB96900080646F60CD39E1210000030020
65
3A904BBF48A10000013807006CCB96900080656F60CD39E1210000030020


Apart:
Keep in mind that you still have a fault in the "new" :?: G85 steering angle you installed.

The basic setting can be made in the ABS unit or in Address 44: Steering Assist (J792) depends on the model and units installed.

Notice (warning):
I don't know how to do the basic setting at address 44, everything you do at address 44 is at your own risk/responsibility.


vento2013 wrote:
Mon Jun 04, 2018 7:33 pm
Tried 66 in byte 18

DRL = OK
Pass Light(Flashing) = OK
Parking light = OK
Low Beam = OK
High Beam = OK
Fog Lights = OK
Static Cornering = OK
But new issue, when high beam is on right low beam flickers once in a while.

So now in byte 18 value is 60
and I turned off SCL.

this is my present coding
Coding: 3A904BBF48A10000013807002CCB96900080604F60C939E1210000030020
except SCL everything else perfect
have two fault codes :?:
:?:

vento2013
New
Posts: 49
Joined: Fri Mar 02, 2018 8:44 am
Drives: 6R Polo(Vento)1.6TDi, Skoda Fabia 1.2MPi
Location: India

Re: Retrofitting LED headlights & BCM Max Adaptation+Auto Headlight with CH/LH on 2013 6R

Post by vento2013 » Wed Jun 20, 2018 7:11 pm

Hello Ciclo,
Sorry for very late reply, was stuck in some work.
Initially SCL was not working later everything stopped working. VCDS scan threw 2 faults Terminal 30 Left N Right 011-Open Circuit. So checked all wiring once again the culprit was loosely inserted ELECTRIC BRIDGE. Reinserted properly. now everything working perfectly.
DRL = OK
Pass Light(Flashing) = OK
Parking light = OK
Low Beam = OK
High Beam = OK
Fog Lights = OK
Static Cornering = OK
Auto headlight = OK
Rain Sensing wiper = OK

04 Steering angle sensor still showing fault code, but SCL working perfectly. Tried doing Basic setting using ODIS, it shown no communication!!

Other than steering angle sensor
There are 2 Faults Found:
00978 - Lamp for Low Beam; Left (M29)

00979 - Lamp for Low Beam; Right (M31)

But Low beam working perfectly. Pls let me know, what might be the issue.
Below is the scan report.

Code: Select all

Monday,04,June,2018,12:26:49:39744
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x86
VCDS Version: 17.1.3.0
Data version: 20170220 DS267.3
www.Ross-Tech.com


VIN: WVWJ13601ET024078   License Plate: KA47M3663
Mileage:    Repair Order: 04062018 8ITBCM



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 60 (7E0)
Scan: 01 03 04 08 09 10 15 17 19 25 44 56 0B

VIN: WVWJ13601ET024078   

01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
56-Radio -- Status: OK 0000
 
-------------------------------------------------------------------------------
Address 01: Engine (J623-CLNA)       Labels: 03L-906-023-CAY.clb
   Part No SW: 03L 906 023 NT    HW: 03L 907 425 B
   Component: 1,6l R4 CR td H33 9971  
   Revision: --H33---    Serial number: 00000000000000
   Coding: 00110016032500080000
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_ECM1T6DI02103L906023NT 003012
   ROD: N/A
   VCID: 05064A5684BA6669DA-8050

No ASAM data for: "EV_ECM1T6DI02103L906023NT" (VW36 *) 
No fault code found.
Readiness: 0000 1000

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels: Redir Fail!
   Part No SW: 6R0 907 379 BF    HW: 6R0 907 379 AQ
   Component: ABS9.0 front  H01 0001  
   Serial number: --------------
   Coding: 60DD2F63212504C40614F470845920020000
   Shop #: WSC 57830 002 1048576
   ASAM Dataset: EV_Brake1AB9S0BOSCH 003017
   ROD: N/A
   VCID: 0302544E8A8E5859F4-8056

No ASAM data for: "EV_Brake1AB9S0BOSCH" (VW25) 
No fault code found.

-------------------------------------------------------------------------------
Address 04: Steering Angle (G085)       Labels: 6R0-959-654.clb
   Part No SW: 6R0 959 654     HW: 6R0 959 654 
   Component: LENKW.SENSOR  H07 0070  
   Serial number: 23101713470492
   Coding: 01
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_LWSKLOVW52X 005001
   ROD: N/A
   VCID: 7EF425BAE16C35B19B-802A

No ASAM data for: "EV_LWSKLOVW52X" (VW25) 
1 Fault Found:
1140738 - ROD - Unknown Error Code 
          - 00 [009]
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 12
                    Mileage: 62403 km
                    Date: 2016.02.17
                    Time: 00:38:22


-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels: 6R0-907-044.clb
   Part No SW: 6R0 907 044 L    HW: 6R0 907 044 L
   Component: Climatronic   H12 0612  
   Revision: V0000000    
   VCID: 3C70EFB2BFF0E7A1F5-8068

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels: 7E0-937-BCM-V1.clb
   Part No SW: 7E0 937 090 C    HW: 7E0 937 090 C
   Component: BCM PQ25 Max4 H82 0752  
   Revision: B9082001    Serial number: 4000 173170900
   Coding: 3A904BBF48A10000013807006CCB96900080606F60CD39E1210000030020  
   Shop #: WSC 12345 123 12345
   VCID: 2B52DCEE4A9E70196C-807E

   Subsystem 1 - Part No: 5K7 955 559 C  Labels: 5K7-955-559.CLB
   Component: RLS 230118 04  47  0106 
   Coding: 0728DD

   Subsystem 2 - Part No SW: 6R0 959 802 AL    HW: 6R0 959 802 AL  Labels: 6R0-959-802.CLB
   Component: -------------  006 5520 
   Serial number: 13202576130625091059
   Coding: 010000

   Subsystem 3 - Part No SW: 6R0 959 801 AH    HW: 6R0 959 801 AH  Labels: 6R0-959-801.CLB
   Component: -------------  006 5520 
   Serial number: 13102579130618031221
   Coding: 010000

   Subsystem 4 - Part No SW: 6C0 959 442     HW: 6C0 959 442 
   Component: E221__MFL-TAT  H04 0019 
   Serial number: 2671409414901055AB1B
   Coding: 240000

   Subsystem 5 - Part No SW: 6R0 959 811 L    HW: 6R0 959 811 L
   Component: -------------  006 5520 
   Serial number: 13102580130620031450
   Coding: 020000

   Subsystem 6 - Part No SW: 6R0 959 812 L    HW: 6R0 959 812 L
   Component: -------------  006 5520 
   Serial number: 13102581130620063454
   Coding: 020000

2 Faults Found:
00978 - Lamp for Low Beam; Left (M29) 
            010 - Open or Short to Plus
             Freeze Frame:
                    Fault Status: 01101010
                    Fault Priority: 3
                    Fault Frequency: 224
                    Reset counter: 12
                    Mileage: 62403 km
                    Time Indication: 0
                    Date: 2016.02.17
                    Time: 00:39:37

00979 - Lamp for Low Beam; Right (M31) 
            010 - Open or Short to Plus
             Freeze Frame:
                    Fault Status: 01101010
                    Fault Priority: 3
                    Fault Frequency: 224
                    Reset counter: 12
                    Mileage: 62403 km
                    Time Indication: 0
                    Date: 2016.02.17
                    Time: 00:39:37


-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446)       Labels: 6R0-919-475.clb
   Part No SW: 6R0 919 475 C    HW: 7E0 919 475 
   Component: PARKHILFE 4K  H11 0013  
   Revision: --------    Serial number: 47361317300143
   Coding: 108002
   Shop #: WSC 00793 648 00255
   ASAM Dataset: EV_VW250ParkiAssis2 S01008
   ROD: EV_VW250ParkiAssis2.rod
   VCID: 3E74E5BAA1ECF5B1DB-806A

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels: 5K0-959-655.clb
   Part No SW: 6R0 959 655 J    HW: 6R0 959 655 J
   Component: VW10AirbagU06 H10 0020  
   Revision: --------    Serial number: 003GW00M0RR+
   Coding: 003036
   Shop #: WSC 01383 785 00200
   ASAM Dataset: EV_AibraVW10BPAVW250 A01001
   ROD: N/A
   VCID: 499E8666E82242097E-801C

No ASAM data for: "EV_AibraVW10BPAVW250" (VW25) 
No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels: 5K0-920-xxx-17.clb
   Part No SW: 6RF 920 862     HW: 6RF 920 862 
   Component: KOMBI         H01 0214  
   Serial number: 00000000000000
   Coding: 140A000000
   Shop #: WSC 13202 938 00000
   ASAM Dataset: EV_Kobmi_UDS_VDD_RM09 A05729
   ROD: N/A
   VCID: 091E4666A8A20209BE-805C

No ASAM data for: "EV_Kobmi_UDS_VDD_RM09" (VW36 *) 
No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels: None
   Part No SW: 7E0 909 901     HW: 7E0 937 090 C
   Component: GW-K-CAN TP20 H82 0752  
   Revision: B9082001    
   Coding: 102300
   Shop #: WSC 12345 123 12345
   VCID: 68D863E29BE89B0141-803C

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels: 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5K0 953 234 
   Component: IMMO          H01 0214  
   Serial number:               
   Coding: 000000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_Mimo_UDS_VDD_RM09 A03710
   ROD: N/A
   VCID: 6ADC19EA8DE4A91157-803E

No ASAM data for: "EV_Mimo_UDS_VDD_RM09" (VW36 *) 
No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist (J792)       Labels: 6Rx-909-144-V1.clb
   Part No SW: 6RF 909 144 K    HW: 6RF 909 144 J
   Component: EPS_ECU       H44 0401  
   Coding: 0000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_SteerAsissUDSNSK 005005
   ROD: N/A
   VCID: 54A0A7123F600FE11D-8000

No ASAM data for: "EV_SteerAsissUDSNSK" (VW25) 
No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (J503)       Labels: None
   Part No SW: 6RD 035 187 B    HW: 6RD 035 187 B
   Component: Radio         534 5314  
   Revision: --------    Serial number: VWZZZ4H6267388
   Coding: 16000440040005
   Shop #: WSC 127395 840 08317
   VCID: 46848D5AF13CAD7193-8012

No fault code found.

End-------------------------(Elapsed Time: 02:41)--------------------------

Post Reply