Giannis20vt's Polo 6c 1.0MPI

Chat about your 6R/6C model Polos here!
Post Reply
User avatar
iichel
Bling Bling Diamond Member
Posts: 6361
Joined: Fri Nov 14, 2014 2:14 pm
Drives: Polo 6R 2.0 TDI, Passat B8 2.0 TSI
Location: http://mypassat.nl/

Re: Giannis20vt's Polo 6c 1.0MPI

Post by iichel »

Use ODIS to install and adapt the BCM
2fast4ya
Getting There!
Posts: 59
Joined: Thu Jun 30, 2016 7:29 pm
Drives: polo 1.8 tsi gti bluetec
Location: ashford kent

Re: Giannis20vt's Polo 6c 1.0MPI

Post by 2fast4ya »

🍿🍺
giannis20vt
Silver Member
Posts: 260
Joined: Sat May 15, 2021 6:23 am
Drives: Polo 6c MY2016 1.0 75Hp
Location: Greece

Re: Giannis20vt's Polo 6c 1.0MPI

Post by giannis20vt »

iichel wrote: Thu Dec 08, 2022 2:12 pm Use ODIS to install and adapt the BCM
I am going to go to a garage with online connection with the VW servers for this job.
I am exciting for this but also i am afraid of failure, i have already tried 3 times to swap the BCM without any luck. The first 2 BCMs were used, the 3rd was "new" but it wasn't so new as the seller claimed.
giannis20vt
Silver Member
Posts: 260
Joined: Sat May 15, 2021 6:23 am
Drives: Polo 6c MY2016 1.0 75Hp
Location: Greece

Re: Giannis20vt's Polo 6c 1.0MPI

Post by giannis20vt »

And suddenly a strange problem. I want your help.
First the right turn signal started working all the time by itself. It stops only when i turn the ignition off.
The left turn signal working fine, as it is suppose to work, but the right doesn't stop at all. The hazard switch working fine also.
I checked all the bulbs and the fuses.
And after an hour trying to find any solution, the car doesn't start. It's not a battery problem, i checked it, even try to start it with wires from another car. Nothing.
I took a message on the screen "Press clutch to start" but i am pressing the clutch.
I unplugged the car battery for half an hour, nothing. I unplugged the BCM still nothing. I am at dead end. Any suggestion, would be appreciated
User avatar
iichel
Bling Bling Diamond Member
Posts: 6361
Joined: Fri Nov 14, 2014 2:14 pm
Drives: Polo 6R 2.0 TDI, Passat B8 2.0 TSI
Location: http://mypassat.nl/

Re: Giannis20vt's Polo 6c 1.0MPI

Post by iichel »

is this problem out of nowhere or after a bcm swap?
giannis20vt
Silver Member
Posts: 260
Joined: Sat May 15, 2021 6:23 am
Drives: Polo 6c MY2016 1.0 75Hp
Location: Greece

Re: Giannis20vt's Polo 6c 1.0MPI

Post by giannis20vt »

iichel wrote: Mon Dec 12, 2022 9:22 pm is this problem out of nowhere or after a bcm swap?
I didn't do anything with the car, apart from some wiring between the roof and the fuse box. I am preparing for the Rain/light sensor installation.

Today i will connect the VCDS to scan for errors.
giannis20vt
Silver Member
Posts: 260
Joined: Sat May 15, 2021 6:23 am
Drives: Polo 6c MY2016 1.0 75Hp
Location: Greece

Re: Giannis20vt's Polo 6c 1.0MPI

Post by giannis20vt »

Lots of errors, it's like nothing is working.
I don't know what to say.
I am thinking of towing the car to a garage for further diagnosis and repair.

Code: Select all

Chassis Type: 6R-VW26 (6C0)
Scan: 01 03 08 09 15 17 19 44 5F

VIN: WVWZZZ6RZGY308378   Mileage: 64776km-40249miles

01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: Malfunction 0010
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: Cannot be reached 0100
17-Instruments -- Status: Malfunction 0010
19-CAN Gateway -- Status: Malfunction 0010
44-Steering Assist -- Status: Malfunction 0010
5F-Information Electr. -- Status: Malfunction 0010
 
-------------------------------------------------------------------------------
Address 01: Engine (J623-CHYB)       Labels:. 04C-906-020-CHY.clb
   Part No SW: 04C 906 057 AB    HW: 04E 907 309 CB
   Component: R3 1.0l MPI   H20 2496  
   Revision: 33H20000    
   Coding: 01110012020400080000
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_ECM10MPI01104C906057AB 001002
   ROD: EV_ECM10MPI01104C906057AB.rod
   VCID: 65C104936461CFA350-8030

3 Faults Found:
5273 - Output for Starter Relay 
          P0616 00 [167] - Short to Ground
          MIL ON - Not Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 64776 km
                    Date: 2022.12.12
                    Time: 21:54:11

                    Engine RPM: 0.00 /min
                    Normed load value: 0.0 %
                    Vehicle speed: 0 km/h
                    Coolant temperature: 12 °C
                    Intake air temperature: 12 °C
                    Ambient air pressure: 990 mbar
                    Voltage terminal 30: 11.049 V
                    Unlearning counter according OBD: 40
                    Starter control: terminal 50 feedback-Bits 0-7: 0
                    Number of manual engine starts-Bits 0-7: 0
                    Number of manual engine starts-Bits 0-7: 0
                    Number of manual engine starts-Bits 0-7: 0
                    Number of manual engine starts-Bits 0-7: 0
                    Number of automatic engine starts-Bits 0-7: 0
                    Number of automatic engine starts-Bits 0-7: 0
                    Number of automatic engine starts-Bits 0-7: 0
                    Number of automatic engine starts-Bits 0-7: 0

5459 - Control Circuit for Starter Relay 2 
          P3048 00 [167] - Short to Ground
          MIL ON - Not Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 64776 km
                    Date: 2022.12.12
                    Time: 21:54:11

                    Engine RPM: 0.00 /min
                    Normed load value: 0.0 %
                    Vehicle speed: 0 km/h
                    Coolant temperature: 12 °C
                    Intake air temperature: 12 °C
                    Ambient air pressure: 990 mbar
                    Voltage terminal 30: 11.049 V
                    Unlearning counter according OBD: 40
                    Starter control: terminal 50 feedback-Bits 0-7: 0
                    Number of manual engine starts-Bits 0-7: 0
                    Number of manual engine starts-Bits 0-7: 0
                    Number of manual engine starts-Bits 0-7: 0
                    Number of manual engine starts-Bits 0-7: 0
                    Number of automatic engine starts-Bits 0-7: 0
                    Number of automatic engine starts-Bits 0-7: 0
                    Number of automatic engine starts-Bits 0-7: 0
                    Number of automatic engine starts-Bits 0-7: 0

4710 - No Communications with Airbag Control Module 
          U0151 00 [039] - -
          Not Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 1
                    Mileage: 64776 km
                    Date: 2022.12.12
                    Time: 21:54:10

                    Engine RPM: 0.00 /min
                    Normed load value: 0.0 %
                    Vehicle speed: 0 km/h
                    Coolant temperature: 12 °C
                    Intake air temperature: 12 °C
                    Ambient air pressure: 990 mbar
                    Voltage terminal 30: 11.049 V
                    Unlearning counter according OBD: 40
                    CAN status - engine control module-Bits 0-7: 0
                    selected gear-Bits 0-7: 0

Readiness: 1110 0001

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels:. 6R0-907-37x-ESP90.clb
   Part No SW: 6C0 907 379 K    HW: 6R0 907 379 BA
   Component: ESP9.0i       H03 0004  
   Serial number: 08512057160424
   Coding: 21DD2485492333C8091700700059842492CC90000005C9098F00
   Shop #: WSC 49716 005 1048576
   ASAM Dataset: EV_Brake1ESP90iBOSCHPQ26 100020
   ROD: EV_Brake1ESP90iBOSCHPQ26.rod
   VCID: 377D9EDB8E4D8D3332-8062

2 Faults Found:
0922 - No Communications with Airbag Control Module 
          U0151 00 [009] - -
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 3
                    Fault Frequency: 1
                    Reset counter: 216
                    Mileage: 64776 km
                    Date: 2022.12.12
                    Time: 21:59:24

1171 - Multiple collision brake 
          B13BC F2 [009] - No function
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 3
                    Fault Frequency: 3
                    Reset counter: 216
                    Mileage: 64776 km
                    Date: 2022.12.12
                    Time: 21:59:24


-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301)       Labels:| 6C0-820-045.clb
   Part No SW: 6C0 820 045 C    HW: 6C0 820 045 C
   Component: AC Manuell    H03 0202  
   Serial number:  1605161B-0418
   Coding: 200000000000100000
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_ACManueKMMValeoPQ26 002001
   ROD: EV_ACManueKMMValeoPQ26.rod
   VCID: 1F4D567B06BDD573DA-804A

4 Faults Found:
262916 - High Pressure Sensor 
          B10AE 14 [013] - Open or Short to Ground
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 216
                    Mileage: 64776 km
                    Date: 2022.12.12
                    Time: 21:55:03

262917 - High Pressure Sensor 
          B10AE 29 [013] - Signal Implausible
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 216
                    Mileage: 64776 km
                    Date: 2022.12.12
                    Time: 21:55:03

459009 - Databus 
          U1121 00 [013] - Missing Message
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 1
                    Reset counter: 216
                    Mileage: 64776 km
                    Date: 2022.12.12
                    Time: 21:55:03

1114115 - Fan 2 Control Circuit 
          P0693 00 [013] - Short to GND
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 216
                    Mileage: 64776 km
                    Date: 2022.12.12
                    Time: 21:55:08


-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:* Redir Fail!
   Part No SW: 6C0 937 087 C    HW: 6C0 937 087 
   Component: BCM PQ26 Me4R H08 0087  
   Serial number: 006088052444
   Coding: 000008404053005B4F844000400703000000580051010000000000000000
   Shop #: WSC 131071 1023 2097151
   ASAM Dataset: EV_BCMA0 005005
   ROD: EV_BCMA0_005.rod
   VCID: 2E53BBBF71174CFB61-807A

   Driver door control module: 
   Subsystem 1 - Part No SW: 6R0 959 801 DG    HW: 6R0 959 801 DG  Labels: 6R0-959-801.CLB
   Component: J386__TSG_FT  003 0610 
   Serial number: KU0KU012051661335260
   Coding: 0000A0

   Front passenger door control module: 
   Subsystem 2 - Part No SW: 6R0 959 802 DL    HW: 6R0 959 802 DL  Labels: 6R0-959-802.CLB
   Component: J387__TSG_BT  003 0610 
   Serial number: KU0KU030041661212448
   Coding: 1000A0

   Rear Driver Side Door Control Module: 
   Subsystem 3 - Part No SW: 6R0 959 811 AA    HW: 6R0 959 811 AA
   Component: J388__TSG_HL  003 0610 
   Serial number: KU0KU028041661198823
   Coding: 0000A0

   Rear Passenger Door Control Module: 
   Subsystem 4 - Part No SW: 6R0 959 812 AA    HW: 6R0 959 812 AA
   Component: J389__TSG_HR  003 0610 
   Serial number: KU0KU002051661233279
   Coding: 1000A0

3 Faults Found:
227080 - Turn Signal Switch 
          B1144 29 [009] - Signal Implausible
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 4
                    Mileage: 64776 km
                    Date: 2022.12.12
                    Time: 21:56:25

528405 - Databus 
          U1121 00 [009] - Missing Message
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 4
                    Fault Frequency: 4
                    Reset counter: 216
                    Mileage: 64776 km
                    Date: 2022.12.12
                    Time: 21:56:25

558101 - Databus 
          U1121 00 [009] - Missing Message
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 3
                    Reset counter: 216
                    Mileage: 64776 km
                    Date: 2022.12.12
                    Time: 21:56:25


-------------------------------------------------------------------------------
Address 15: Airbags
Cannot be reached

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 5G0-920-XXX-17.clb-SRI3
   Part No SW: 6C0 920 740 C    HW: 6C0 920 740 C
   Component: KOMBI         201 1420  
   Coding: 0724090021000008110828000000000000000000
   Shop #: WSC 49716 005 104857
   ASAM Dataset: EV_DashBoardVDDMQBAB 009046
   ROD: EV_DashBoardVDDMQBAB_009_VW26.rod
   VCID: 224B5F8F35CFF89BF5-8076

3 Faults Found:
13697024 - Component Protection 
          U1100 00 [009] - No Basic Setting
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 4
                    Fault Frequency: 1
                    Reset counter: 195
                    Mileage: 63548 km
                    Date: 2022.01.14
                    Time: 00:07:17

16776962 - Databus 
          U1121 00 [009] - Missing Message
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 3
                    Reset counter: 216
                    Mileage: 64776 km
                    Date: 2022.12.12
                    Time: 21:58:26

9603840 - Incorrect Key Programming for Remote Control 
          B128B 00 [009] - -
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 26
                    Mileage: 63548 km
                    Date: 2022.01.14
                    Time: 17:45:46


-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels:| 6C0-909-901-V1.clb
   Part No SW: 6C0 909 901     HW: 6C0 937 087 
   Component: GW MQB A0     H08 0087  
   Revision: --------    Serial number: 006088052444
   Coding: 01000008200A640071000000000000000001010000000000000000000000
   Shop #: WSC 12345 123 12345
   ASAM Dataset: EV_GatewA0Lear 013020
   ROD: EV_GatewA0Lear_013_VW26.rod
   VCID: 65C104936461CFA350-8030

1 Fault Found:
131605 - No Communications with Airbag Control Module 
          U0151 00 [009] - -
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 216
                    Mileage: 64776 km
                    Date: 2022.12.12
                    Time: 21:56:52

                    Terminal 30 power supply: 11.2 V
                    Terminal 15: On


-------------------------------------------------------------------------------
Address 44: Steering Assist (J792)       Labels:| 6Rx-909-144-V2.clb
   Part No SW: 6C1 909 144 AG    HW: 6C1 909 144 D
   Component: EPS_TRW_ALow  312 3232  
   Serial number: PG5Q1139
   Coding: 000700
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_SteerAssisUDSTRW 016026
   ROD: EV_SteerAssisUDSTRW.rod
   VCID: 6DD17CB3BC91F7E318-8038

9 Faults Found:
1072128 - Databus 
          U1121 00 [008] - Missing Message
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 2
                    Reset counter: 1

                    Engine RPM: 0 /min
                    Vehicle speed: 0.00 km/h
                    System status: Waiting for start request
                    Terminal 15 status: Terminal 15 on
                    Voltage terminal 30: 10.71 V
                    Power steering current consumption: 0.50 A
                    max.value: 0.50 A
                    End stage temperature: 21 °C
                    Steering assistance: engine output: 0.00 %
                    Engine angle: 0 °
                    Electric motor speed: 0 /min
                    Steering assistance: target engine torque: 0.00 Nm
                    Steering torque: 0.08 Nm
                    Status: OK

1065472 - Databus 
          U1121 00 [008] - Missing Message
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 2
                    Reset counter: 1

                    Engine RPM: 0 /min
                    Vehicle speed: 0.00 km/h
                    System status: Waiting for start request
                    Terminal 15 status: Terminal 15 on
                    Voltage terminal 30: 11.09 V
                    Power steering current consumption: 0.50 A
                    max.value: 0.50 A
                    End stage temperature: 21 °C
                    Steering assistance: engine output: 0.00 %
                    Engine angle: 0 °
                    Electric motor speed: 0 /min
                    Steering assistance: target engine torque: 0.00 Nm
                    Steering torque: 0.08 Nm
                    Status: OK

1066752 - Function Restricted due to Insufficient Voltage 
          U1400 00 [008] - -
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 1
                    Mileage: 64772 km
                    Date: 2022.12.11
                    Time: 00:16:31

                    Engine RPM: 153 /min
                    Vehicle speed: 19.88 km/h
                    System status: Driving mode
                    Terminal 15 status: Terminal 15 on
                    Voltage terminal 30: 8.54 V
                    Power steering current consumption: 0.50 A
                    max.value: 24.82 A
                    End stage temperature: 30 °C
                    Steering assistance: engine output: 0.95 %
                    Engine angle: 158 °
                    Electric motor speed: 7 /min
                    Steering assistance: target engine torque: 0.00 Nm
                    Steering torque: 0.27 Nm
                    Status: OK

1068288 - Databus 
          U1121 00 [008] - Missing Message
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 1
                    Reset counter: 1

                    Engine RPM: 0 /min
                    Vehicle speed: 0.00 km/h
                    System status: Waiting for start request
                    Terminal 15 status: Terminal 15 on
                    Voltage terminal 30: 11.29 V
                    Power steering current consumption: 0.50 A
                    max.value: 0.50 A
                    End stage temperature: 21 °C
                    Steering assistance: engine output: 0.00 %
                    Engine angle: 0 °
                    Electric motor speed: 0 /min
                    Steering assistance: target engine torque: 0.00 Nm
                    Steering torque: 0.11 Nm
                    Status: OK

1068800 - Databus 
          U1121 00 [008] - Missing Message
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 2
                    Reset counter: 1

                    Engine RPM: 0 /min
                    Vehicle speed: 0.00 km/h
                    System status: Waiting for start request
                    Terminal 15 status: Terminal 15 on
                    Voltage terminal 30: 10.71 V
                    Power steering current consumption: 0.50 A
                    max.value: 0.50 A
                    End stage temperature: 21 °C
                    Steering assistance: engine output: 0.00 %
                    Engine angle: 0 °
                    Electric motor speed: 0 /min
                    Steering assistance: target engine torque: 0.00 Nm
                    Steering torque: 0.08 Nm
                    Status: OK

1070336 - Databus 
          U1121 00 [008] - Missing Message
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 2
                    Reset counter: 1

                    Engine RPM: 0 /min
                    Vehicle speed: 0.00 km/h
                    System status: Waiting for start request
                    Terminal 15 status: Terminal 15 on
                    Voltage terminal 30: 11.32 V
                    Power steering current consumption: 0.50 A
                    max.value: 0.50 A
                    End stage temperature: 21 °C
                    Steering assistance: engine output: 0.00 %
                    Engine angle: 0 °
                    Electric motor speed: 0 /min
                    Steering assistance: target engine torque: 0.00 Nm
                    Steering torque: 0.08 Nm
                    Status: OK

1069568 - Databus 
          U1121 00 [008] - Missing Message
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 1
                    Reset counter: 1

                    Engine RPM: 0 /min
                    Vehicle speed: 0.00 km/h
                    System status: Waiting for start request
                    Terminal 15 status: Terminal 15 on
                    Voltage terminal 30: 11.29 V
                    Power steering current consumption: 0.50 A
                    max.value: 0.50 A
                    End stage temperature: 21 °C
                    Steering assistance: engine output: 0.00 %
                    Engine angle: 0 °
                    Electric motor speed: 0 /min
                    Steering assistance: target engine torque: 0.00 Nm
                    Steering torque: 0.11 Nm
                    Status: OK

1048832 - Databus 
          U1121 00 [009] - Missing Message
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 1
                    Reset counter: 216
                    Date: 2000.00.00
                    Time: 00:00:00

                    Engine RPM: 0 /min
                    Vehicle speed: 0.00 km/h
                    System status: Waiting for start request
                    Terminal 15 status: Terminal 15 on
                    Voltage terminal 30: 12.00 V
                    Power steering current consumption: 0.50 A
                    max.value: 0.50 A
                    End stage temperature: 17 °C
                    Steering assistance: engine output: 0.00 %
                    Engine angle: 0 °
                    Electric motor speed: 0 /min
                    Steering assistance: target engine torque: 0.00 Nm
                    Steering torque: -0.02 Nm
                    Status: OK

1052160 - Databus 
          U1121 00 [008] - Missing Message
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 2
                    Reset counter: 1

                    Engine RPM: 0 /min
                    Vehicle speed: 0.00 km/h
                    System status: Waiting for start request
                    Terminal 15 status: Terminal 15 on
                    Voltage terminal 30: 11.09 V
                    Power steering current consumption: 0.50 A
                    max.value: 0.50 A
                    End stage temperature: 21 °C
                    Steering assistance: engine output: 0.00 %
                    Engine angle: 0 °
                    Electric motor speed: 0 /min
                    Steering assistance: target engine torque: 0.00 Nm
                    Steering torque: 0.08 Nm
                    Status: OK


-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794)       Labels:| 5G0-035-MIB-ENT2.clb
   Part No SW: 6C0 035 888 B    HW: 6C0 035 888 B
   Component: MU-E--ER      851 6490  
   Serial number: 19041600012060
   Coding: 026200003C00000041110001010000001F0000840000010001
   Shop #: WSC 00788 648 00255
   ASAM Dataset: EV_MUEnt4CGen2LGE 001025
   ROD: EV_MUEnt4CGen2LGE_VW26.rod
   VCID: 2B55B2AB420539D346-807E

1 Fault Found:
6697 - Databus 
          U1121 00 [009] - Missing Message
          [New feature! Extended UDS fault detail is only supported by current gen. interfaces]
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 1
                    Reset counter: 216
                    Mileage: 64776 km
                    Date: 2022.12.12
                    Time: 22:01:51

                    Voltage terminal 30: 11.0 V
                    Network diagnosis-Status: Enabled


End-------------------------(Elapsed Time: 02:15)--------------------------
Last edited by giannis20vt on Tue Dec 13, 2022 8:08 pm, edited 1 time in total.
User avatar
iichel
Bling Bling Diamond Member
Posts: 6361
Joined: Fri Nov 14, 2014 2:14 pm
Drives: Polo 6R 2.0 TDI, Passat B8 2.0 TSI
Location: http://mypassat.nl/

Re: Giannis20vt's Polo 6c 1.0MPI

Post by iichel »

looks like a ground point in your interior wiring harness is having a bad time. but that's a very rough guess!
giannis20vt
Silver Member
Posts: 260
Joined: Sat May 15, 2021 6:23 am
Drives: Polo 6c MY2016 1.0 75Hp
Location: Greece

Re: Giannis20vt's Polo 6c 1.0MPI

Post by giannis20vt »

iichel wrote: Tue Dec 13, 2022 8:06 pm looks like a ground point in your interior wiring harness is having a bad time. but that's a very rough guess!
It's a thought that i have done, but it is very difficult to search it.
User avatar
iichel
Bling Bling Diamond Member
Posts: 6361
Joined: Fri Nov 14, 2014 2:14 pm
Drives: Polo 6R 2.0 TDI, Passat B8 2.0 TSI
Location: http://mypassat.nl/

Re: Giannis20vt's Polo 6c 1.0MPI

Post by iichel »

Yes, I agree it's not easy. Here I'm seeing an increase in failures of electrical components due to water/corrosion because of cold weather and bad batteries.
I would start with a certain error like a starter relay and measure all wires to it. Or find a common denominator in the wiring schemes like a relay, ground point, fuse, etc.
giannis20vt
Silver Member
Posts: 260
Joined: Sat May 15, 2021 6:23 am
Drives: Polo 6c MY2016 1.0 75Hp
Location: Greece

Re: Giannis20vt's Polo 6c 1.0MPI

Post by giannis20vt »

I am reading the faults and i feel very sad.
To much error codes, so much different issues. I really hope this ends easily without many changes and big costs.
Today I am going to tow the car to a garage for further diagnosis and repair.
User avatar
iichel
Bling Bling Diamond Member
Posts: 6361
Joined: Fri Nov 14, 2014 2:14 pm
Drives: Polo 6R 2.0 TDI, Passat B8 2.0 TSI
Location: http://mypassat.nl/

Re: Giannis20vt's Polo 6c 1.0MPI

Post by iichel »

I understand, this is a complex case. But I think you can get a good start with simply a wiring diagram and a multimeter. You can very easily reach the E box in the engine bay, for example, where the starter relays are.
giannis20vt
Silver Member
Posts: 260
Joined: Sat May 15, 2021 6:23 am
Drives: Polo 6c MY2016 1.0 75Hp
Location: Greece

Re: Giannis20vt's Polo 6c 1.0MPI

Post by giannis20vt »

Image
giannis20vt
Silver Member
Posts: 260
Joined: Sat May 15, 2021 6:23 am
Drives: Polo 6c MY2016 1.0 75Hp
Location: Greece

Re: Giannis20vt's Polo 6c 1.0MPI

Post by giannis20vt »

Update for those problems.

1rst problem: broken stalks (turn signal switch). It gives signal for the right turn light all the time. :(
2nd problem. 2 broken fuses (i checked all the fuses without removing all of them). Maybe i didn't check them right or i took a false measurement. :shock:
3rd problem. I remove a couple of fuses from the fusebox to check the operation of their circuit, but i didn't put them to the right place :oops:

On the garage the electrician guy found the problem in 15 minutes. I was sure for the faulty stalks because i test them with my original ones.

So final the car is running again without any problem until now.
User avatar
iichel
Bling Bling Diamond Member
Posts: 6361
Joined: Fri Nov 14, 2014 2:14 pm
Drives: Polo 6R 2.0 TDI, Passat B8 2.0 TSI
Location: http://mypassat.nl/

Re: Giannis20vt's Polo 6c 1.0MPI

Post by iichel »

Make a picture of your fusebox next time before you work on it.
Post Reply